Electrochemical behaviour of iron and AISI 304 stainless steel in simulated acid rain solution
-
Zora Pilić
Abstract
The growth mechanism and properties of the oxide films on iron and AISI 304 stainless steel were studied in simulated acid rain (pH 4.5) by means of electrochemical techniques and atomic absorption spectrometry. The layer-pore resistance model was applied to explain a potentiodynamic formation of surface oxides. It was found that the growth of the oxide film on iron takes place by the low-field migration mechanism, while that on the stainless steel takes place by the high-field mechanism. Kinetic parameters were determined. Impedance measurements revealed that Fe surface film has no protective properties at the open circuit potential, while the resistance of stainless steel oxide film is very high. The concentration of the metallic ions released into solution and measured by atomic absorption spectroscopy was in accordance with the results obtained from the electrochemical techniques.
References
[1] M.Nagayama, M.Cohen: J. Electrochem. Soc.109 (1962) 781. 10.1149/1.2425555Suche in Google Scholar
[2] M.Nagayama, M.Cohen: J. Electrochem. Soc.110 (1963) 670. 10.1149/1.2425849Suche in Google Scholar
[3] V.Schroeder, T.M.Devine: J. Electrochem. Soc.146 (1999) 4061. 10.1149/1.1392592Suche in Google Scholar
[4] M.E.Brett, K.M.Parkin, M.J.Graham: J. Electrochem. Soc.133 (1986) 2031. 10.1149/1.2108334Suche in Google Scholar
[5] R.W.Revie, B.G.Baker, J.O'M.Bockris: J. Electrochem. Soc.122 (1975) 1460. 10.1149/1.2134042Suche in Google Scholar
[6] M.F.Toney: Phys. Rev. Lett.79 (1997) 4282. 10.1103/PhysRevLett.79.4282Suche in Google Scholar
[7] S.Marcelin, N.Pebere, S.Regnier: Electrochim. Acta87 (2013) 32. 10.1016/j.electacta.2012.09.011Suche in Google Scholar
[8] T.L.Sudesh, L.Wijesinghe, D.J.Blackwood: Corros. Sci.50 (2008) 23. 10.1016/j.corsci.2007.06.009Suche in Google Scholar
[9] M.G.S.Ferreira, N.E.Hakiki, G.Goodlet, S.Faty, A.M.P.Simoes, M.Da Cunha Belo: Electrochim. Acta46 (2001) 3767. 10.1016/S0013-4686(01)00658-2Suche in Google Scholar
[10] S.Fujimoto, H.Tsuchiya: Corros. Sci.49 (2007) 195. 10.1016/j.corsci.2006.05.020Suche in Google Scholar
[11] A.Kocijan, Č.Donik, M.Jenko: Corros. Sci.49 (2007) 2083. 10.1016/j.corsci.2006.11.001Suche in Google Scholar
[12] N.Ramasubramanian, N.Preocanin, R.D.Davidson: J. Electrochem. Soc.132 (1985) 793. 10.1149/1.2113959Suche in Google Scholar
[13] R.F.A.Jargelius-Pettersson, B.G.Pound: J. Electrochem. Soc.145 (1998) 1462. 10.1149/1.1838505Suche in Google Scholar
[14] C.Calinski, H.-H.Strehblow: J. Electrochem. Soc.136 (1989) 1328. 10.1149/1.2096915Suche in Google Scholar
[15] N.E.Hakiki, M.Da Cunha Belo, A.M.P.Simoes, M.G.S.Ferreira: J. Electrochem. Soc.145 (1998) 3821. 10.1149/1.1838880Suche in Google Scholar
[16] I.Olefjord, B.Bronx, U.Jelvestam: J. Electrochem. Soc.132 (1985) 2854. 10.1149/1.2113683Suche in Google Scholar
[17] G.Lorang, M.Da Cuhna Belo, A.M.P.Simoes, M.G.S.Ferreira: J. Electrochem. Soc.141 (1994) 3347. 10.1149/1.2059338Suche in Google Scholar
[18] N.De Cristofaro, M.Piantini, N.Zacchetti: Corros. Sci.39 (12) (1997) 2181. 10.1016/S0010-938X(97)00101-7Suche in Google Scholar
[19] X.Zuo, B.Xiang, X.Li, Z.Wei: J. Mater. Eng. Perform.21 (2012) 524. 10.1007/s11665-011-9931-2Suche in Google Scholar
[20] M. BajtLeban, C.Mikyška, T.Kosec, B.Markoli, J.Kovač: J. Mater. Eng. Perform.23 (2014) 1695. 10.1007/s11665-014-0940-9Suche in Google Scholar
[21] I.Martinović, Z.Pilić, I.Dragičević, A.Višekruna: Int. J. Mater. Res.106 (2015) 1067. 10.3139/146.111278Suche in Google Scholar
[22] I.Mišković, Z.Pilić: Int. J. Electrochem. Sci.8 (2013) 7926.Suche in Google Scholar
[23] G.Seufert, V.Hoyer, H.Wollmer, U.Arndt: Environ. Pollut.68 (1990) 205. 10.1016/0269-7491(90)90028-BSuche in Google Scholar
[24] L.Li, C.Wang, S.Chen, X.Yang, B.Yuan, H.Jia: Electrochim. Acta53 (2008) 3109. 10.1016/j.electacta.2007.11.040Suche in Google Scholar
[25] T.L.Sudesh, L.Wijesinghe, D.J.Blackwood: Appl. Surf. Sci.253 (2006) 1006. 10.1016/j.apsusc.2006.03.081Suche in Google Scholar
[26] M.Abdallah: Mater. Chem. Phys.82 (2003) 786. 10.1016/S0254-0584(03)00367-5Suche in Google Scholar
[27] W.J.Muller: Trans. Faraday Soc.27 (1931) 737. 10.1039/TF9312700737Suche in Google Scholar
[28] A.J.Calandra, N.R.Tacconi, R.Pereiro, A.J.Arvia: Electrochim. Acta19 (1974) 901. 10.1016/0013-4686(74)85041-3Suche in Google Scholar
[29] M.Metikoš-Huković, R.Babić: Corros. Sci.49 (2007) 3570. 10.1016/j.corsci.2007.03.023Suche in Google Scholar
[30] D.Williams, G.A.Wright: Electrochim. Acta21 (1976) 1009. 10.1016/0013-4686(76)85079-7Suche in Google Scholar
[31] S.J.Ahn, H.S.Kwon, D.D.Macdonald: J. Electrochem. Soc.152, (2005) B482. 10.1149/1.2048247Suche in Google Scholar
[32] S.J.Ahn, H.S.Kwon: J. Electroanal. Chem.579 (2005) 311. 10.1016/j.jelechem.2005.03.003Suche in Google Scholar
[33] R.Babić, M.Metikoš-Huković, Z. Pilić: Corrosion59 (2003) 890. 10.5006/1.3287710Suche in Google Scholar
[34] E.Sikora, D.D.Macdonald: J. Electrochem. Soc.147 (2000) 4087. 10.1149/1.1394024Suche in Google Scholar
[35] C.Q.Cheng, J.Zhao, T.S.Cao, Q.Q.Fu, M.K.Lei, D.W.Deng: Corros. Sci.70 (2013) 235. 10.1016/j.corsci.2013.01.035Suche in Google Scholar
[36] A.Kocijan, D. KekMerl, M.Jenko: Corros. Sci.53 (2011) 776. 10.1016/j.corsci.2010.11.010Suche in Google Scholar
[37] C.Pallotta, N.De Cristofano, R.C.Salvarezza, A.J.Arvia: Electrochim. Acta31 (1986) 1265. 10.1016/0013-4686(86)80146-3Suche in Google Scholar
[38] M.Urretabizkaya, C.Pallotta, N.De Cristofano, R.C.Salvarezza, A.J.Arvia: Electrochim. Acta33 (1988) 1645. 10.1016/0013-4686(88)80237-8Suche in Google Scholar
[39] R.M.Souto, I.C. MirzaRosca, S.Gonzales: Corrosion57 (2001) 300. 10.5006/1.3290353Suche in Google Scholar
[40] M.Metikoš-Huković, Z.Pilić, R.Babić, D.Omanović: Acta Biomater.2 (2006) 693. 10.1016/j.actbio.2006.06.002Suche in Google Scholar
[41] M.Bojinov, I.Betova, G.Fabricius, T.Laitinen, R.Raicheff, T.Saario: Corros. Sci.41 (1999) 1557. 10.1016/S0010-938X(99)00003-7Suche in Google Scholar
[42] Ž.Petrović, N.Lajçi, M.Metikoš-Huković, R.Babić: J. Solid State Electrochem.15 (2011) 1201. 10.1007/s10008-010-1192-8Suche in Google Scholar
[43] M.J.Dignam, in: J.O'M.Bockris, B.E.Conway, E.Yeager, R.E.White (Eds.) Comprehensive Treatise of Electrochemistry, Vol. 4, Plenum Pub. Corp., New York (1981) 247.Suche in Google Scholar
[44] E.M.Patrito, R.M.Torresi, E.P.M.Leiva, V.A.Macagno: J. Electrochem. Soc.137 (1990) 524. 10.1149/1.2086492Suche in Google Scholar
[45] V.Brunetti, M. LopezTeijelo: J. Electroanal. Chem.613 (2008) 16. 10.1016/j.jelechem.2007.10.001Suche in Google Scholar
[46] O.E. LinarezPérez, M.A.Pérez, M.López Teijelo: J. Electroanal. Chem.632 (2009) 64. 10.1016/j.jelechem.2009.03.018Suche in Google Scholar
[47] T.P.Moffat, R.H.Latanision: J. Electrochem. Soc.139 (1992) 1869. 10.1149/1.2069514Suche in Google Scholar
[48] S.Omanović, M.Metikoš-Huković: Solid State Ionics78 (1995) 69. 10.1016/0167-2738(95)00009-USuche in Google Scholar
[49] M.Bojinov, I.Betova, R.Raicheff: J. Electroanal. Chem.411 (1996) 37. 10.1016/0022-0728(96)04591-3Suche in Google Scholar
[50] R.M.Souto, I.C. MirzaRosca, S.Gonzales: Corrosion57 (2001) 300. 10.5006/1.3290353Suche in Google Scholar
[51] J.R.Macdonald: Impedance spectroscopy, emphasizing solid materials and systems, Wiley, New York (1987).Suche in Google Scholar
[52] E.M.A.Martini, I.L.Muller: Corros. Sci.42 (2000) 443. 10.1016/S0010-938X(99)00064-5Suche in Google Scholar
[53] U.Rammelt, G.Reinhard: Electrochim. Acta35 (1990) 1045. 10.1016/0013-4686(90)90040-7Suche in Google Scholar
[54] P.Marcus: Electrochim. Acta43 (1998) 109. 10.1016/S0013-4686(97)00239-9Suche in Google Scholar
© 2016, Carl Hanser Verlag, München
Artikel in diesem Heft
- Contents
- Contents
- Original Contributions
- A metastable phase diagram for the dynamic transformation of austenite at temperatures above the Ae3
- Experimental investigation of phase equilibria in the Co–Ni–Zr ternary system
- Phase equilibria of the Ni–Sb–Zn system at 600 °C
- High frequency cycling behaviour of three AZ magnesium alloys – microstructural characterisation
- Influence of auxetic foam in quasi-static axial crushing
- Electrochemical behaviour of iron and AISI 304 stainless steel in simulated acid rain solution
- Mechanochemical synthesis of CaMoO4 nanoparticles: kinetics and characterization
- Synthesis and characterization of iron oxide nanoparticles prepared hydrothermally at different reaction temperatures and pH
- Influence of SPS parameters on the density and hardness of zinc selenide
- Investigation into the kinetic behavior of molten aluminum pressureless infiltration into SiC preforms
- Review
- Centrifugal casting technique baseline knowledge, applications, and processing parameters: overview
- People
- Prof. Dr.-Ing. Jürgen Hirsch on the occasion of his 65th birthday
- DGM News
- DGM News
Artikel in diesem Heft
- Contents
- Contents
- Original Contributions
- A metastable phase diagram for the dynamic transformation of austenite at temperatures above the Ae3
- Experimental investigation of phase equilibria in the Co–Ni–Zr ternary system
- Phase equilibria of the Ni–Sb–Zn system at 600 °C
- High frequency cycling behaviour of three AZ magnesium alloys – microstructural characterisation
- Influence of auxetic foam in quasi-static axial crushing
- Electrochemical behaviour of iron and AISI 304 stainless steel in simulated acid rain solution
- Mechanochemical synthesis of CaMoO4 nanoparticles: kinetics and characterization
- Synthesis and characterization of iron oxide nanoparticles prepared hydrothermally at different reaction temperatures and pH
- Influence of SPS parameters on the density and hardness of zinc selenide
- Investigation into the kinetic behavior of molten aluminum pressureless infiltration into SiC preforms
- Review
- Centrifugal casting technique baseline knowledge, applications, and processing parameters: overview
- People
- Prof. Dr.-Ing. Jürgen Hirsch on the occasion of his 65th birthday
- DGM News
- DGM News
