Startseite Phase equilibria and thermal analysis in the Fe–Mn–Ni system
Artikel
Lizenziert
Nicht lizenziert Erfordert eine Authentifizierung

Phase equilibria and thermal analysis in the Fe–Mn–Ni system

  • Lijun Zhang , Yong Du , Honghui Xu , Shuhong Liu , Yajun Liu , Feng Zheng , Nathalie Dupin , Huaiying Zhou und Chengying Tang
Veröffentlicht/Copyright: 11. Juni 2013
Veröffentlichen auch Sie bei De Gruyter Brill
Informationen für Autor*innen
International Journal of Materials Research
Aus der Zeitschrift International Journal of Materials Research Band 100 Heft 2

Abstract

Based on the critical review of the experimental data available in the literature, 7 decisive ternary alloys were prepared. New phase transition temperatures and phase equilibria at 800°C in the Fe – Mn – Ni system were measured. An effective method to accurately determine phase transition temperatures from differential thermal analysis curves with overlapped peaks and nonlevel baselines within a narrow temperature range was developed. A massive transformation was observed in one quenched Fe-rich alloy. In order to make the fcc_A1 phase always in the fully disordered state in the ternary system, the effect of the binary reciprocal parameter on the Gibbs energy of ternary ordered L12 phase was considered. It was found that the introduction of only one parameter could describe all reliable experimental data in the Fe – Mn – Ni system satisfactorily. The presently obtained parameters were successfully applied in two practical cases.

Keywords: Fe – Mn – Ni phase diagram; Massive transformation; Differential thermal analysis; Thermodynamic calculation; Order/disorder transformations
* Correspondence address, Professor Dr. Yong Du, State Key Laboratory of Powder Metallurgy, Central South University, Changsha, Hunan 410083, P.R. China, Tel.: +86 731 8836 213, Fax: +86 731 8710 855, E-mail:

References

[1] V.A.Chernenko, E.Cesari, V.V.Kokorin, I.N.Vitenko: Scr. Metall. Mater.33 (1995) 1239.Suche in Google Scholar

[2] G.H.Wu, C.H.Yu, L.Q.Meng, J.L.Chen, F.M.Yang, S.R.Qi, W.S.Zhan, Z.Wang, Y.F.Zheng, L.C.Zhao: Appl. Phys. Lett.75 (1999) 2990.Suche in Google Scholar

[3] S.J.Murray, M.Marioni, S.M.Allen, R.C.O'Handley, T.A.Lograsso: Appl. Phys. Lett.77 (2000) 886.Suche in Google Scholar

[4] V.V.Khovailo, R.Kainuma, T.Abe, K.Oikawa, T.Takagi: Scr. Mater.51 (2004) 13.Suche in Google Scholar

[5] A.A.Cherechukina, I.E.Dikshteina, D.I.Ermakova, A.V.Glebova, V.V.Koledova, D.A.Kosolapova, V.G.Shavrov, A.A.Tulaikovaa, E.P.Krasnoperovb, T.Takagic: Phys. Lett. A291 (2001) 175.Suche in Google Scholar

[6] H.B.Wang, F.Chen, Z.Y.Gao, W.Cai, L.C.Zhao: Mater. Sci. Eng. A438 (2006) 990.Suche in Google Scholar

[7] C.Picornell, J.Pons, E.Cesari, J.Dutkiewicz: Intermetallics16 (2008) 751.Suche in Google Scholar

[8] Y.Q.Wu, F.X.Yin, K.Hono: Scr. Mater.46 (2002) 717.Suche in Google Scholar

[9] L.J.Zhang, Y.Du, H.H.Xu, C.Y.Tang, H.L.Chen, W.Q.Zhang: J. Alloys. Compd.454 (2008) 129.Suche in Google Scholar

[10] L.J.Zhang, Y.Du: CALPHAD31 (2007) 529.Suche in Google Scholar

[11] Y.Du, J.C.Schuster, Z.-K.Liu, R.X.Hu, P.Nash, W.H.Sun, W.W.Zhang, J.Wang, L.J.Zhang, C.Y.Tang, Z.J.Zhu, S.H.Liu, Y.F.Ouyang, W.Q.Zhang, N.Krendelsberger: Intermetallics16 (2008) 554.Suche in Google Scholar

[12] L.J.Zhang, Y.Du, Q.Chen, H.H.Xu, F.Zheng, C.Y.Tang, H.L.Chen: Int. J. Mat. Res.99 (2008) 1306.Suche in Google Scholar

[13] N.Parravano: Inter. Z. Metallogr.4 (1913) 171.Suche in Google Scholar

[14] V.G.Rivlin, G.V.Raynor: Int. Met. Rev.28 (1983) 23.Suche in Google Scholar

[15] G.V.Raynor, V.G.Rivlin: Phase Equilibria in Iron Ternary Alloys, Vol. 4, The Institute of Metals, London (1988) 361.Suche in Google Scholar

[16] V.Raghavan: J. Phase. Equilib.15 (1994) 617.10.1007/BF02647624Suche in Google Scholar

[17] D.M.Kundrat: Metall. Tans. A17 (1986) 1825.10.1007/BF02817279Suche in Google Scholar

[18] V.M.Danilenko, V.Z.Trukevich: Izv. Akad. Nauk SSSR, Met.2 (1987) 209.Suche in Google Scholar

[19] V.Z.Turkevich: Sverkhtverd. Mater. v Nar. Kh-ve, Kiev. (1989) 29.Suche in Google Scholar

[20] K.C.Harikumar, V.Raghavan: J. Alloy Phase Diagrams4 (1989) 53.Suche in Google Scholar

[21] K.C.Harikumar, V.Raghavan: J. Alloy Phase Diagrams5 (1989) 201.Suche in Google Scholar

[22] J.Miettinen: CALPHAD22 (1998) 275.10.1016/S0364-5916(98)00028-5Suche in Google Scholar

[23] P.Franke: Int. J. Mater. Res.98 (2007) 954.10.3139/146.101558Suche in Google Scholar

[24] S.H.Liu, Y.Du, L.J.Zhang: CALPHAD (2008) to be submitted.Suche in Google Scholar

[25] Y.A.Kocherzhinskii, O.G.Kulik, V.Z.Trukevich: Izv. Akad. Nauk SSSR, Met.4 (1985) 210.Suche in Google Scholar

[26] E.Schuermann, M.Djurdjevic, L.Nedeljkovic: Steel. Res.68 (1997) 512.Suche in Google Scholar

[27] V.I.Goman'kovV.I.Kleinerman, B.N.Tret'yakov, A.I.Zaitsev: Fizika. Metallov i Metallovedenie61 (1986) 1136.Suche in Google Scholar

[28] V.I.Goman'kovA.I.Zaitsev, V.I.Kleinerman: Izv. Akad. Nauk SSSR, Met.2 (1986) 204.Suche in Google Scholar

[29] T.B.Massalski: Binary Alloy Phases Diagrams, 2nd ed., ASM International, Metals Park, OH (1986) 1086.Suche in Google Scholar

[30] T.B.Massalski: Binary Alloy Phases Diagrams, 2nd ed., ASM International, Metals Park, OH (1986) 1573.Suche in Google Scholar

[31] L.Ding, P.F.Ladwig, X.Y.Yan, Y.A.Chang: Appl. Phys. Lett.80 (2002) 1186.Suche in Google Scholar

[32] N.N.Kurnakov, M.Y.Tronev: Izvest. Sektora Fiz. Khim. Analiza Inst. Obshchei i Neorg. Khim. Akad. Nauk S.S.S.R.24 (1954) 132.Suche in Google Scholar

[33] S.Kaya, M.Nakayama, H.Sato: Proc. Phys. Math. Soc. Japan25 (1943) 179.Suche in Google Scholar

[34] I.L.Eganyan, Y.P.Selisskii: Fizika Metallov i Metallovedenie23 (1967) 369.Suche in Google Scholar

[35] B.Ganguli, V.Meherotra, K.P.Gupta: Trans. Indian Inst. Met.44 (1991) 187.Suche in Google Scholar

[36] J.H.Smith, H.W.Paxton, C.L.McCabe: J. Phys. Chem.68 (1964) 1345.Suche in Google Scholar

[37] K.Mukai, A.Uchida, T.Tagami, Y.Wasai, in: Proceedings of the third international iron and steel congress, ASM, Metals Park, OH (1978) 266.Suche in Google Scholar

[38] W.M.Huang: CALPHAD13 (1989) 243.10.1016/0364-5916(89)90004-7Suche in Google Scholar

[39] C.Servant, B.Sundman, O.Lyon: CALPHAD25 (2001) 79.Suche in Google Scholar

[40] I.Ansara, N.Dupin, H.L.Lukas, B.Sundman: J. Alloys. Compd.247 (1997) 20.Suche in Google Scholar

[41] N.Dupin, I.Ansara, B.Sundman: CALPHAD25 (2001) 279.Suche in Google Scholar

[42] O.Redlich, A.T.Kister: Ind. Eng. Chem.40 (1948) 341.Suche in Google Scholar

[43] A.T.Dinsdale: CALPHAD15 (1991) 317.10.1016/0364-5916(91)90030-NSuche in Google Scholar

[44] G.Inden, in: The proceedings of CALPHAD V project meeting, Max-Planck Institute for Metal Research, Dusseldorf (1976) 1.Suche in Google Scholar

[45] M.Hillert, M.Jarl: CALPHAD2 (1978) 227.Suche in Google Scholar

[46] M.Hillert, L.I.Staffansson: Acta Chem. Scand.24 (1970) 3618.Suche in Google Scholar

[47] B.Sundman, J.Ågren: J. Phys. Chem. Solids42 (1981) 297.Suche in Google Scholar

[48] B.Sundamn, S.G.Fries, W.A.Oates: CALPHAD22 (1998) 335.Suche in Google Scholar

[49] L.Vegard: Z. Phys.5 (1921) 17.10.1007/BF01349680Suche in Google Scholar

[50] L.Vegard: Z. Kristallogr.67 (1928) 482.10.1126/science.67.1741.482.bSuche in Google Scholar

[51] T.B.Massalski: Binary Alloy Phases Diagrams, 2nd ed., ASM International, Metals Park, OH (1986) 1078.Suche in Google Scholar

[52] J.O.Andersson, T.Helander, L.Höglund, P.F.Shi, B.Sundman: CALPHAD26 (2002) 273.Suche in Google Scholar

[53] Y.Du, R.Schmid-Fetzer, H.Ohtani: Z. Metallkd.88 (1997) 545.Suche in Google Scholar

[54] A.Costa e Silva, J.Ågren, M.T.Clavaguera–Mora, D.Djurovic, T.Gomez–Acebo, B.J.Lee, Z.-K.Liu, P.Miodownik, H.J.Seifert: CALPHAD31 (2007) 53.Suche in Google Scholar

[55] T.P.Battle, R.D.Pehlke: Metall. Trans. B20 (1989) 149.Suche in Google Scholar

[56] T.Takahashi, M.Kudo, K.Ichikawa: Solidification of iron and steel: A data book on the solidification phenomena of iron and steel, Solidification Committee, Joint Society Iron Steel Basic Research of ISIJ, Tokyo (1977).Suche in Google Scholar

[57] O.Kubaschewski: Iron-binary phase diagrams, Springer-Verlag, New York (1982).Suche in Google Scholar

[58] J.F.Elliott, in: C.R.Taylor, C.C.Custer (Eds.), Electric furnace steelmaking, Iron and steel society, Warrendale, PA (1985) 294.Suche in Google Scholar

[59] M.D.Perkas, V.I.Snitsar: Phys. Met. Metallorg.17 (1964) 400.Suche in Google Scholar

[60] J.A.Goldman, J.Manenc: Trans. ASM58 (1965) 645.Suche in Google Scholar

[61] D.R.Squires, E.A.Wilson: Metall. Trans.3 (1972) 575.Suche in Google Scholar

[62] N.H.Heo: Acta Mater.44 (1996) 3015.10.1016/1359-6454(95)00355-XSuche in Google Scholar

[63] S.H.Mun, M.Watanabe, X.Y.Li, K.H.Oh, D.B.Williams, H.C.Lee: Metall. Mater. Trans. A33 (2002) 1057.Suche in Google Scholar

[64] H.C.Lee, S.H.Mun, D.McKenzie: Metall. Mater. Trans. A34 (2003) 2421.Suche in Google Scholar

Received: 2008-9-17
Accepted: 2008-11-13
Published Online: 2013-06-11
Published in Print: 2009-02-01

© 2009, Carl Hanser Verlag, München

Artikel in diesem Heft

  1. Contents
  2. Contents
  3. Feature
  4. Materials constitution and computational thermodynamics in the context of 100 years of IJMR – Zeitschrift für Metallkunde
  5. Upgrading CALPHAD to microstructure simulation: the phase-field method
  6. Prediction, determination and validation of phase diagrams via the global study of energy landscapes
  7. Alloy development using modern tools
  8. Phase equilibria and thermal analysis in the Fe–Mn–Ni system
  9. Integrated approach to thermodynamics, phase relations, liquid densities and solidification microstructures in the Al–Bi–Cu system
  10. Formation of clathrates Ba–M–Ge(M = Mn, Fe, Co)
  11. New paradigm of a metastable phase diagram presenting structural transformations induced by annealing of Si–C–N amorphous ceramics derived from polymer precursors
  12. Basic
  13. Thermodynamic assessment of the Ce–Si, Y–Si, Mg–Ce–Si and Mg–Y–Si systems
  14. Thermodynamic re-assessment of the Ti–Al–Nb system
  15. Effect of varying oxygen partial pressure on the properties of reactively evaporated zinc aluminate thin films
  16. Applied
  17. Matrix induced synthesis of Y3Al5O12: Ce phosphor through the Pechini method
  18. Microstructure and room temperature compressive properties of holmium doped DS NiAl-Cr(Mo)-Hf eutectic alloy
  19. Evaporation mechanism of aluminum during electron beam cold hearth melting of Ti64 alloy
  20. 560°C isothermal section of the Zn–Fe–Ni–Si quaternary system at the zinc-rich corner
  21. DGM News
  22. Personal
https://doi.org/10.3139/146.110002
Schlagwörter für diesen Artikel
Fe – Mn – Ni phase diagram; Massive transformation; Differential thermal analysis; Thermodynamic calculation; Order/disorder transformations

Artikel in diesem Heft

  1. Contents
  2. Contents
  3. Feature
  4. Materials constitution and computational thermodynamics in the context of 100 years of IJMR – Zeitschrift für Metallkunde
  5. Upgrading CALPHAD to microstructure simulation: the phase-field method
  6. Prediction, determination and validation of phase diagrams via the global study of energy landscapes
  7. Alloy development using modern tools
  8. Phase equilibria and thermal analysis in the Fe–Mn–Ni system
  9. Integrated approach to thermodynamics, phase relations, liquid densities and solidification microstructures in the Al–Bi–Cu system
  10. Formation of clathrates Ba–M–Ge(M = Mn, Fe, Co)
  11. New paradigm of a metastable phase diagram presenting structural transformations induced by annealing of Si–C–N amorphous ceramics derived from polymer precursors
  12. Basic
  13. Thermodynamic assessment of the Ce–Si, Y–Si, Mg–Ce–Si and Mg–Y–Si systems
  14. Thermodynamic re-assessment of the Ti–Al–Nb system
  15. Effect of varying oxygen partial pressure on the properties of reactively evaporated zinc aluminate thin films
  16. Applied
  17. Matrix induced synthesis of Y3Al5O12: Ce phosphor through the Pechini method
  18. Microstructure and room temperature compressive properties of holmium doped DS NiAl-Cr(Mo)-Hf eutectic alloy
  19. Evaporation mechanism of aluminum during electron beam cold hearth melting of Ti64 alloy
  20. 560°C isothermal section of the Zn–Fe–Ni–Si quaternary system at the zinc-rich corner
  21. DGM News
  22. Personal
Jetzt anmelden und 20% sparen
Institutioneller Zugang
Wie funktioniert Authentifizierung?
Haben Sie eine Idee, wie wir unsere Website verbessern können?
Bitte schreiben Sie uns.
© 2025 De Gruyter Brill
Heruntergeladen am 16.11.2025 von https://www.degruyterbrill.com/document/doi/10.3139/146.110002/html
Button zum nach oben scrollen