Peculiarities of Diffusion Controlled Phase Formation in the Al–Co System
-
Boris Bokstein
and
Mikhail Klimov
Abstract
By using differential scanning microcalorimetry, X-ray phase analysis, electron microscopy and secondary ionmass spectrometry, the phase formation was studied in Al –Co powder, prepared by mechanical alloying, and also in Al –Co thin films of Al13Co4 composition. It was shown that solid-phase reaction between Al and Co starts from Al9Co2 formation. The heat of Al9Co2 formation was estimated, approximately the same in both types of materials. In mechanically alloyed powders the Al9Co2 phase formed at lower temperatures than in thin films. The growth of the Al9Co2 phase is a two-stage process. It is supposed that the first stage is controlled by Co diffusion in Al, and the second stage is controlled by Co diffusion through the intermetallic phase Al9Co2.
References
1 Hansen, M.; Anderko, K.: Constitution of Binary Alloys, McGraw-Hill, New York (1958) 96.10.1149/1.2428700Search in Google Scholar
2 Calgan, E.G.; Mayer, J.M.: J. Mater. Res. 4 (1989) 815.10.1557/JMR.1989.0815Search in Google Scholar
3 Emeric, E.; Bergmen, C.; Clugnet, G.; Gas, P.; Audier, M.: Phil. Mag. Lett. 78 (1998) 77.10.1080/095008398178057Search in Google Scholar
4 Calgan, E.G.: Mater. Sci. Rep. 5 (1990) 1.10.1016/S0920-2307(05)80005-2Search in Google Scholar
5 Emeric, E.: Ph.D. Thesis, Univ. of d’Aix-Marseille III (1998).Search in Google Scholar
6 Peterson, N.L.; Rothman, S.J.: Phys. Rev. B 1 (1970) 3264.10.1103/PhysRevB.1.3264Search in Google Scholar
7 Anand, A.; Agarwala, R.P.: Phil. Mag. 26 (1972) 927.10.1080/14786437208227429Search in Google Scholar
8 Kaur, I.; Gust, W.; Kozma, L.: Handbook of Grain and Interphase Boundary Diffusion Data, Ziegler Press, Stuttgart (1989).Search in Google Scholar
9 Dupin, N.: Ph.D. Thesis, Inst. Nat. Polytech. Grenoble (1995). Search in Google Scholar
10 Mehrer, H. (ed.):Diffision in Solid Metals and Alloys, Landolt – Börnstein New Series, Vol. III/26, Springer, Berlin (1997).Search in Google Scholar
© 2001 Carl Hanser Verlag, München
Articles in the same Issue
- Frontmatter
- Editorial
- Dieter Neuschütz 65 Years
- Aufsätze/Articles
- Combinatorial Methods for Advanced Materials Research & Development
- Chemische Gasphasenabscheidung von SiC und SiC + Si auf Kohlenstoffsubstraten und ihre chemische Oberflächenmodifizierung
- Fabrication and Characterization of Hydrogen Absorption LaNi5 Alloy Films Sputtered on Nickel Substrate
- On the Importance of Gas Phase Chemistry in Two CVD Systems: Deposition of Silicon and Diamond
- Thermodynamic Prediction of Metastable Coating Structures in PVD Processes
- Setting Kinetic Controls for Complex Equilibrium Calculations
- Modeling of the Thermochemical Properties of Multicomponent Oxide Melts
- Subsolidus Phase Relationships of the β–Sialon Solid Solution in the Oxygen-Rich Part of the Nd–Si–Al–O–N System
- Investigation of Microstructure and Chemical Stability in Composites of NiAl Reinforced by Alumina-Silica Fibers
- Gesicherte Interpretationen der FTIR-Reflexionsspektren von SiC–CVD-Schichten durch Spektrensimulation
- Characterization of Cohesion, Adhesion and Creep-Properties of Dynamically Loaded Coatings through the Impact Tester
- Peculiarities of Diffusion Controlled Phase Formation in the Al–Co System
- Mitteilungen/Notifications
- Personen
- Bücher/Books
- Tagungen
Articles in the same Issue
- Frontmatter
- Editorial
- Dieter Neuschütz 65 Years
- Aufsätze/Articles
- Combinatorial Methods for Advanced Materials Research & Development
- Chemische Gasphasenabscheidung von SiC und SiC + Si auf Kohlenstoffsubstraten und ihre chemische Oberflächenmodifizierung
- Fabrication and Characterization of Hydrogen Absorption LaNi5 Alloy Films Sputtered on Nickel Substrate
- On the Importance of Gas Phase Chemistry in Two CVD Systems: Deposition of Silicon and Diamond
- Thermodynamic Prediction of Metastable Coating Structures in PVD Processes
- Setting Kinetic Controls for Complex Equilibrium Calculations
- Modeling of the Thermochemical Properties of Multicomponent Oxide Melts
- Subsolidus Phase Relationships of the β–Sialon Solid Solution in the Oxygen-Rich Part of the Nd–Si–Al–O–N System
- Investigation of Microstructure and Chemical Stability in Composites of NiAl Reinforced by Alumina-Silica Fibers
- Gesicherte Interpretationen der FTIR-Reflexionsspektren von SiC–CVD-Schichten durch Spektrensimulation
- Characterization of Cohesion, Adhesion and Creep-Properties of Dynamically Loaded Coatings through the Impact Tester
- Peculiarities of Diffusion Controlled Phase Formation in the Al–Co System
- Mitteilungen/Notifications
- Personen
- Bücher/Books
- Tagungen
