Process optimization for extraction of avian eggshell membrane derived collagen for tissue engineering applications

Aakriti Aggarwal; Mahesh Kumar Sah

doi:10.1515/polyeng-2021-0315

Artikel

Process optimization for extraction of avian eggshell membrane derived collagen for tissue engineering applications

Aakriti Aggarwal und Mahesh Kumar Sah

Veröffentlicht/Copyright: 9. Mai 2022

Veröffentlicht von

Veröffentlichen auch Sie bei De Gruyter Brill

Manuskript einreichen Informationen für Autor*innen

Aus der Zeitschrift Journal of Polymer Engineering Band 42 Heft 7

Abstract

The avian eggshell membranes’ composition depicts close resemblance with the extracellular matrix of the cells, and therefore being widely employed as potential biomaterials for tissue engineering applications. However, the optimization of process conditions for collagen extraction, the main constituent of eggshell membranes is still challenging. In the present study, extraction of collagen was performed by an enzymatic method optimized through the one-factor-at-a-time (OFAT) technique for three parameters viz. pepsin concentration, treatment time and pH. The process optimization resulted in the maximum yield of 56% collagen with 350 U/mg pepsin concentration at pH 3 treated for 9 days, not reported yet. The collagen extraction was confirmed by OD at 232 nm; and its viscoelasticity behaviour at pH 5. The physico–chemical characterization of extracted collagen with FESEM, ATR-FTIR, surface roughness analysis and contact angle measurement revealed the morphological and topological alteration during the collagen extraction. The process optimization and characterization of eggshell membrane derived collagen can aid in the significant biomaterials development for tissue regeneration.

Keywords: biopolymer; collagen; eggshell membrane; OFAT; protein yield

Corresponding author: Mahesh Kumar Sah, Department of Biotechnology, Dr. B. R. Ambedkar National Institute of Technology, Jalandhar, Punjab 144011, India, E-mail: sahmk@nitj.ac.in

Acknowledgments

We are also thankful to Dr. Giri Babu (Dept. of Chemical Engineering) for carrying out viscosity studies, Dr. Vickramjeet Singh (Dept. of Chemistry) for contact angle measurements, and Dr. A. Chatterjee (Dept. of Textile Technology) for ATR-FTIR measurements.

Author contribution: All the authors have accepted responsibility for the entire content of this submitted manuscript and approved submission.
Research funding: We acknowledge the support from MHRD (Govt. of India) to Aakriti Aggarwal for completion of this research work.
Conflict of interest statement: The authors declare that they have no conflicts of interest regarding this article.

References

1. Mohammadi, R., Mohammadifar, M. A., Mortazavian, A. M., Rouhi, M., Ghasemi, J. B., Delshadian, Z. Extraction optimization of pepsin-soluble collagen from eggshell membrane by response surface methodology (RSM). Food Chem. 2016, 190, 186–193; https://doi.org/10.1016/j.foodchem.2015.05.073.Suche in Google Scholar PubMed

2. Rodríguez, M. I. A., Barroso, L. G. R., Sánchez, M. L. Collagen: a review on its sources and potential cosmetic applications. J. Cosmet. Dermatol. 2018, 17, 20–26.10.1111/jocd.12450Suche in Google Scholar PubMed

3. Dan, W., Chen, Y., Dan, N., Zheng, X., Wang, L., Yang, C., Huang, Y., Liu, X., Hu, Y. Multi-level collagen aggregates and their applications in biomedical applications. Int. J. Polym. Anal. Char. 2019, 24, 667–683; https://doi.org/10.1080/1023666x.2019.1656387.Suche in Google Scholar

4. Shi, Y., Zhou, K., Li, D., Guyonnet, V., Hincke, M. T., Mine, Y. Avian eggshell membrane as a novel biomaterial: a review. Foods 2021, 10, 2178; https://doi.org/10.3390/foods10092178.Suche in Google Scholar PubMed PubMed Central

5. Radwan-Pragłowska, J., Piątkowski, M., Janus, Ł., Bogdał, D., Matysek, D., Cablik, V. 3D scaffolds prepared from acylated chitosan applicable in skin regeneration – synthesis and characterization. Int. J. Polym. Anal. Char. 2019, 24, 75–86.10.1080/1023666X.2018.1553348Suche in Google Scholar

6. Liu, D., Liang, L., Regenstein, J. M., Zhou, P. Extraction and characterisation of pepsin-solubilised collagen from fins, scales, skins, bones and swim bladders of bighead carp (Hypophthalmichthys nobilis). Food Chem. 2012, 133, 1441–1448; https://doi.org/10.1016/j.foodchem.2012.02.032.Suche in Google Scholar

7. Kaczmarek, B., Sionkowska, A., Łukowicz, K., Osyczka, A. M. Characterization of scaffolds based on chitosan and collagen with glycosaminoglycans. Int. J. Polym. Anal. Char. 2019, 24, 374–380; https://doi.org/10.1080/1023666x.2019.1598639.Suche in Google Scholar

8. Wang, L., Yang, B., Du, X. Extraction of acid-soluble collagen from grass carp (Ctenopharyngodon idella) skin. J. Food Process. Eng. 2009, 32, 743–751; https://doi.org/10.1111/j.1745-4530.2008.00242.x.Suche in Google Scholar

9. Seixas, M. J., Martins, E., Reis, R. L., Silva, T. H. Extraction and characterization of collagen from elasmobranch byproducts for potential biomaterial use. Mar. Drugs 2020, 18, 617; https://doi.org/10.3390/md18120617.Suche in Google Scholar PubMed PubMed Central

10. Ramanathan, G., Singaravelu, S., Muthukumar, T., Thyagarajan, S., Rathore, H. S., Sivagnanam, U. T., Perumal, P. T. Fabrication of Arothron stellatus skin collagen film incorporated with Coccinia grandis as a durable wound construct. Int. J. Polym. Mater. Polym. Biomater. 2017, 66, 558–568; https://doi.org/10.1080/00914037.2016.1252351.Suche in Google Scholar

11. Alparce, N., Noomhorm, A., Anal, A. Sequential extraction of hyaluronic acid and collagen from chicken eggshell membrane. Innov. Food Ingred. Food Safety 2018, 13–27.Suche in Google Scholar

12. Raftery, R. M., Woods, B., Marques, A. L. P., Moreira-Silva, J., Silva, T. H., Cryan, S.-A., Reis, R. L., O’Brien, F. J. Multifunctional biomaterials from the sea: assessing the effects of chitosan incorporation into collagen scaffolds on mechanical and biological functionality. Acta Biomater. 2016, 43, 160–169; https://doi.org/10.1016/j.actbio.2016.07.009.Suche in Google Scholar

13. Shaik, M. I., Effendi, N. A., Sarbon, N. M. Functional properties of sharpnose stingray (Dasyatis zugei) skin collagen by ultrasonication extraction as influenced by organic and inorganic acids. Biocatal. Agric. Biotechnol. 2021, 35, 102103; https://doi.org/10.1016/j.bcab.2021.102103.Suche in Google Scholar

14. Kheirabadi, E. K., hadi Razavi, S., Khodaiyan, F., Golmakani, M.-T. Optimizing the extraction of acid-soluble collagen inside the eggshell membrane. Food Sci. Technol. Res. 2018, 24, 385–394; https://doi.org/10.3136/fstr.24.385.Suche in Google Scholar

15. Ponkham, W., Limroongreungrat, K., Sangnark, A. Extraction of collagen from hen eggshell membrane by using organic acids. Thai J. Agric. Sci. 2011, 44, 354–360.Suche in Google Scholar

16. Nor, N. M., Mohamed, M. S., Loh, T. C., Foo, H. L., Rahim, R. A., Tan, J. S., Mohamad, R. Comparative analyses on medium optimization using one-factor-at-a-time, response surface methodology, and artificial neural network for lysine–methionine biosynthesis by Pediococcus pentosaceus RF-1. Biotechnol. Biotechnol. Equip. 2017, 31, 935–947.10.1080/13102818.2017.1335177Suche in Google Scholar

17. Sah, M. K., Banerjee, I., Pramanik, K. Eggshell membrane protein modified silk fibroin-poly vinyl alcohol scaffold for bone tissue engineering. J. Biomim. Biomater. Biomed. Eng. 2017, 32, 69–81; https://doi.org/10.4028/www.scientific.net/jbbbe.32.69.Suche in Google Scholar

18. Kulshreshtha, G., Ahmed, T. A. E., Wu, L., Diep, T., Hincke, M. T. A novel eco-friendly green approach to produce particalized eggshell membrane (PEM) for skin health applications. Biomater. Sci. 2020, 8, 5346–5361; https://doi.org/10.1039/d0bm01110j.Suche in Google Scholar

19. Yu-Hong, Z., Yu-Jie, C. Characterization of collagen from eggshell membrane. Biotechnology 2009, 8, 254–258.10.3923/biotech.2009.254.258Suche in Google Scholar

20. Lowry, O. H., Rosebrough, N. J., Farr, A. L., Randall, R. J. Protein measurement with the Folin phenol reagent. J. Biol. Chem. 1951, 193, 265–275; https://doi.org/10.1016/s0021-9258(19)52451-6.Suche in Google Scholar

21. Schneider, C. A., Rasband, W. S., Eliceiri, K. W. NIH Image to ImageJ: 25 years of image analysis. Nat. Methods 2012, 9, 671–675; https://doi.org/10.1038/nmeth.2089.Suche in Google Scholar PubMed PubMed Central

22. Álvarez-Suarez, A. S., López-Maldonado, E. A., Graeve, O. A., Martinez-Pallares, F., Gómez-Pineda, L. E., Oropeza-Guzmán, M. T., Iglesias, A. L., Ng, T., Serena-Gómez, E., Villarreal-Gómez, L. J. Fabrication of porous polymeric structures using a simple sonication technique for tissue engineering. J. Polym. Eng. 2017, 37, 943–951.10.1515/polyeng-2016-0423Suche in Google Scholar

23. Chinga Carrasco, G., Johnsen, P., Dougherty, R., Berli, E., Walter, J. Quantification of the 3-D micro-structure of SC surfaces. J. Microsc. 2007, 227, 254–265; https://doi.org/10.1111/j.1365-2818.2007.01809.x.Suche in Google Scholar PubMed

24. Maher, M., Castilho, M., Yue, Z., Glattauer, V., Hughes, T. C., Ramshaw, J. A., Wallace, G. G. Shaping collagen for engineering hard tissues: towards a printomics approach. Acta Biomater. 2021, 131, 41–61; https://doi.org/10.1016/j.actbio.2021.06.035.Suche in Google Scholar PubMed

25. Uquillas, J. A., Akkus, O. Modeling the electromobility of type-I collagen molecules in the electrochemical fabrication of dense and aligned tissue constructs. Ann. Biomed. Eng. 2012, 40, 1641–1653; https://doi.org/10.1007/s10439-012-0528-1.Suche in Google Scholar PubMed

26. Wang, L., Yang, B., Wang, R., Du, X. Extraction of pepsin-soluble collagen from grass carp (Ctenopharyngodon idella) skin using an artificial neural network. Food Chem. 2008, 111, 683–686; https://doi.org/10.1016/j.foodchem.2008.04.037.Suche in Google Scholar

27. Bae, I., Osatomi, K., Yoshida, A., Osako, K., Yamaguchi, A., Hara, K. Biochemical properties of acid-soluble collagens extracted from the skins of underutilised fishes. Food Chem. 2008, 108, 49–54; https://doi.org/10.1016/j.foodchem.2007.10.039.Suche in Google Scholar

28. Guha Ray, P., Pal, P., Srivas, P. K., Basak, P., Roy, S., Dhara, S. Surface modification of eggshell membrane with electrospun chitosan/polycaprolactone nanofibers for enhanced dermal wound healing. ACS Appl. Bio Mater. 2018, 1, 985–998; https://doi.org/10.1021/acsabm.8b00169.Suche in Google Scholar PubMed

29. Yu, F., Zong, C., Jin, S., Zheng, J., Chen, N., Huang, J., Chen, Y., Huang, F., Yang, Z., Tang, Y., Ding, G. Optimization of extraction conditions and characterization of pepsin-solubilised collagen from skin of giant croaker (Nibea japonica). Mar. Drugs 2018, 16, 29; https://doi.org/10.3390/md16010029.Suche in Google Scholar PubMed PubMed Central

30. Tsai, W. T., Yang, J. M., Lai, C. W., Cheng, Y. H., Lin, C. C., Yeh, C. W. Characterization and adsorption properties of eggshells and eggshell membrane. Bioresour. Technol. 2006, 97, 488–493; https://doi.org/10.1016/j.biortech.2005.02.050.Suche in Google Scholar PubMed

Received: 2021-11-12

Revised: 2022-02-26

Accepted: 2022-03-23

Published Online: 2022-05-09

Published in Print: 2022-08-26

Sie haben derzeit keinen Zugang zu diesem Inhalt.

Artikel in diesem Heft

https://doi.org/10.1515/polyeng-2021-0315

Schlagwörter für diesen Artikel

biopolymer; collagen; eggshell membrane; OFAT; protein yield