Volume 60, Issue 5 - Special Issue: Magnetic nanoparticles for biomedical applications / Guest Editor: Lutz Trahms

High gradient magnetic separation is a well-established technology in the mineral processing industry, and has been used for decades in the bioprocessing industry. Less well known is the increasing role that high gradient magnetic separation is playing in biomedical applications, for both diagnostic and therapeutic purposes. We review here the state of the art in this emerging field, with a focus on therapeutic haemofiltration, the key enabling technologies relating to the functionalisation of magnetic nanoparticles with target-specific binding agents, and the development of extra-corporeal circuits to enable the in situ filtering of human blood.

Magnetic nanoparticles (MNPs) are used in different biomedical applications, whereby each application requires specific particle properties. To fulfill these requirements, particle properties have to be optimized by means of variation of crystal structure, particle size, and size distribution. To this aim, improved aqueous precipitation procedures for magnetic iron oxide nanoparticle synthesis were developed. One procedure focused on the cyclic growth of MNPs without nucleation of new particle cores during precipitation. The second novel particle type are magnetic multicore nanoparticles, which consist of single cores of approximately 10 nm forming dense clusters in the size range from 40 to 80 nm. Their highest potential features these multicore particles in hyperthermia application. In our in vivo experiments, therapeutically suitable temperatures were reached after 20 s of heating for a particle concentration in the tumor of 1% and field parameters of H =24 kA/m and f =410 kHz. This review on our recent investigations for particle optimization demonstrates that tuning magnetic properties of MNPs can be obtained by the alteration of their structure, size, and size distribution. This can be realized by means of control of particle size during synthesis or subsequent size-dependent fractionation. The here-developed particles show high potential for biomedical applications.

Background: A deeper knowledge on the effects of the degradation of magnetic nanoparticles on their magnetic properties is required to develop tools for the identification and quantification of magnetic nanoparticles in biological media by magnetic means. Methods: Citric acid and phosphonoacetic acid-coated magnetic nanoparticles have been degraded in a medium that mimics lysosomal conditions. Magnetic measurements and transmission electron microscopy have been used to follow up the degradation process. Results: Particle size is reduced significantly in 24 h at pH 4.5 and body temperature. These transformations affect the magnetic properties of the compounds. A reduction of the interparticle interactions is observed just 4 h after the beginning of the degradation process. A strong paramagnetic contribution coming from the degradation products appears with time. Conclusions: A model for the in vivo degradation of magnetic nanoparticles has been followed to gain insight on the changes of the magnetic properties of iron oxides during their degradation. The degradation kinetics is affected by the particle coating, in our case being the phosphonoacetic acid-coated particles degraded faster than the citric acid-coated ones.

Background: Quantitative knowledge about the spatial distribution and local environment of magnetic nanoparticles (MNPs) inside an organism is essential for guidance and improvement of biomedical applications such as magnetic hyperthermia and magnetic drug targeting. Magnetorelaxometry (MRX) provides such quantitative information by detecting the magnetic response of MNPs following a fast change in the applied magnetic field. Methods: In this article, we review our MRX based procedures that enable both the characterization and the quantitative imaging of MNPs in a biomedical environment. Results: MRX characterization supported the selection of an MNP system with colloidal stability and suitable cellular MNP uptake. Spatially resolved MRX, a procedure employing multi-channel MRX measurements allowed for in-vivo monitoring of the MNP distribution in a pre-clinical carcinoma animal model. Extending spatially resolved MRX by consecutive magnetization of distinct parts of the sample led to a demonstration of MRX tomography. With this tomography, we reconstructed the three dimensional MNP distribution inside animal sized phantoms with a sensitivity of milligrams of MNPs per cm 3 . In addition, the targeting efficiency of MNPs in whole blood was assessed using a flow phantom and MRX quantification. Conclusion: These MRX based measurement and analysis procedures have substantially supported the development of MNP based biomedical applications.

Background: Here we describe superparamagnetic relaxometry (SPMR), a technology that utilizes highly sensitive magnetic sensors and superparamagnetic nanoparticles for cancer detection. Using SPMR, we sensitively and specifically detect nanoparticles conjugated to biomarkers for various types of cancer. SPMR offers high contrast in vivo , as there is no superparamagnetic background, and bones and tissue are transparent to the magnetic fields. Methods: In SPMR measurements, a brief magnetizing pulse is used to align superparamagnetic nanoparticles of a discrete size. Following the pulse, an array of superconducting quantum interference detectors (SQUID) sensors detect the decaying magnetization field. NP size is chosen so that, when bound, the induced field decays in seconds. They are functionalized with specific biomarkers and incubated with cancer cells in vitro to determine specificity and cell binding. For in vivo experiments, functionalized NPs are injected into mice with xenograft tumors, and field maps are generated to localize tumor sites. Results: Superparamagnetic NPs developed here have small size dispersion. Cell incubation studies measure specificity for different cell lines and antibodies with very high contrast. In vivo animal measurements verify SPMR localization of tumors. Our results indicate that SPMR possesses sensitivity more than 2 orders of magnitude better than previously reported.

This study implements nonlinear susceptibility magnitude imaging (SMI) with multifrequency intermodulation and phase encoding. An imaging grid was constructed of cylindrical wells of 3.5-mm diameter and 4.2-mm height on a hexagonal two-dimensional 61-voxel pattern with 5-mm spacing. Patterns of sample wells were filled with 40-μl volumes of Fe 3 O 4 starch-coated magnetic nanoparticles (mNPs) with a hydrodynamic diameter of 100 nm and a concentration of 25 mg/ml. The imaging hardware was configured with three excitation coils and three detection coils in anticipation that a larger imaging system will have arrays of excitation and detection coils. Hexagonal and bar patterns of mNP were successfully imaged ( R 2 >0.9) at several orientations. This SMI demonstration extends our prior work to feature a larger coil array, enlarged field-of-view, effective phase encoding scheme, reduced mNP sample size, and more complex imaging patterns to test the feasibility of extending the method beyond the pilot scale. The results presented in this study show that nonlinear SMI holds promise for further development into a practical imaging system for medical applications.

Nanomedicine and superparamagnetic iron oxide nanoparticles (SPIONs) are thought to have an important impact on medicine in the future. Especially in cancer therapy, SPIONs offer the opportunity of improving the effectivity of the treatment and reduce side effects by magnetic accumulation of SPION-bound chemotherapeutics in the tumor area. Although still some challenges have to be overcome, before the new treatment concept of magnetic drug targeting will reach the patients, substantial progress has been made, and promising results were shown in the last years.

Experiments and numerical simulations using a flow phantom for magnetic drug targeting have been undertaken. The flow phantom is a half y-branched tube configuration where the main tube represents an artery from which a tumour-supplying artery, which is simulated by the side branch of the flow phantom, branches off. In the experiments a quantification of the amount of magnetic particles targeted towards the branch by a magnetic field applied via a permanent magnet is achieved by impedance measurement using sensor coils. Measuring the targeting efficiency, i.e. the relative amount of particles targeted to the side branch, for different field configurations one obtains targeting maps which combine the targeting efficiency with the magnetic force densities in characteristic points in the flow phantom. It could be shown that targeting efficiency depends strongly on the magnetic field configuration. A corresponding numerical model has been set up, which allows the simulation of targeting efficiency for variable field configuration. With this simulation good agreement of targeting efficiency with experimental data has been found. Thus, the basis has been laid for future calculations of optimal field configurations in clinical applications of magnetic drug targeting. Moreover, the numerical model allows the variation of additional parameters of the drug targeting process and thus an estimation of the influence, e.g. of the fluid properties on the targeting efficiency. Corresponding calculations have shown that the non-Newtonian behaviour of the fluid will significantly influence the targeting process, an aspect which has to be taken into account, especially recalling the fact that the viscosity of magnetic suspensions depends strongly on the magnetic field strength and the mechanical load.

Introduction: Herceptin is an expensive humanized antibody used for the treatment of early-stage breast cancers. This antibody can cause cardiotoxicity in some patients. In this study, we evaluated the possibility of increasing the therapeutic efficacy of Herceptin by combining magnetic nanoparticles and a permanent magnet for more accumulation in the tumor site. Methods: Herceptin magnetic nanoparticles (HMNs) were synthesized and some of their characteristics, such as stability, magnetization, particle size by transmission electron microscopy (TEM), and dynamic light scattering (DLS) technique, were measured. The biodistribution study was checked in mice bearing breast tumor with and without a permanent magnet on the position of the tumor. The therapeutic effects of HMNs were considered in this condition. Results: The size distribution of HMNs determined by the DLS technique was 182±7 nm and the average size by TEM was 100±10 nm. The reductions of 81% and 98% in the mean tumor volume for the group that received HMNs with magnetic field were observed at 42 and 45 days after injection, respectively. Conclusion: The good results in mice indicated that Herceptin-loaded iron oxide nanoparticles with external magnetic field have good potential for use in humans as a targeted drug delivery that needs more investigation.

Magnetic nanoparticles (MNPs) can interact with alternating magnetic fields (AMFs) to deposit localized energy for hyperthermia treatment of cancer. Hyperthermia is useful in the context of multimodality treatments with radiation or chemotherapy to enhance disease control without increased toxicity. The unique attributes of heat deposition and transfer with MNPs have generated considerable attention and have been the focus of extensive investigations to elucidate mechanisms and optimize performance. Three-dimensional (3D) simulations are often conducted with the finite element method (FEM) using the Pennes’ bioheat equation. In the current study, the Pennes’ equation was modified to include a thermal damage-dependent perfusion profile to improve model predictions with respect to known physiological responses to tissue heating. A normal distribution of MNPs in a model liver tumor was combined with empirical nanoparticle heating data to calculate tumor temperature distributions and resulting survival fraction of cancer cells. In addition, calculated spatiotemporal temperature changes were compared among magnetic field amplitude modulations of a base 150-kHz sinusoidal waveform, specifically, no modulation, sinusoidal, rectangular, and triangular modulation. Complex relationships were observed between nanoparticle heating and cancer tissue damage when amplitude modulation and damage-related perfusion profiles were varied. These results are tantalizing and motivate further exploration of amplitude modulation as a means to enhance efficiency of and overcome technical challenges associated with magnetic nanoparticle hyperthermia (MNH).

The treatment of tumors via hyperthermia has gained increased attention in the last years. Among the different modalities available so far, magnetic hyperthermia has the particular advantage of offering the possibility of depositing the heating source directly into the tumor. In this study, we summarized the present knowledge we gained on how to improve the therapeutic efficiency of magnetic hyperthermia using magnetic nanoparticles (MNPs), with particular consideration of the intratumoral infiltration of the magnetic material. We found that (1) MNPs will be mainly immobilized at the tumor area and that this aspect has to be considered when estimating the heating potential of MNPs, (2) the intratumoral distribution patterns via slow infiltration might well be modulated by specific MNP coating and magnetic targeting, (3) imaging of the nanoparticle depositions within the tumor might allow to correct the distribution pattern via multiple applications, (4) multiple therapeutic sessions are feasible because MNPs are not delivered from the tumor site during the heating process, (5) the utilization of MNPs that internalize into cells will favor the production of intracellular heating spots rather than extracellular ones, (6) utilization of MNPs functionalized with chemotherapeutic agents will allow us to exploit the additive effects of both therapeutic modalities, and (7) distinct cytopathological and histopathological alterations in target tissues are induced as a result of magnetic hyperthermia. However, the accumulation at the tumor via intravenous application remains a matter of challenge.