Interference of Zr(IV) during the extraction of trivalent Nd(III) from the aqueous waste generated from metallic fuel reprocessing
-
T. Prathibha
Abstract
A metallic alloy of uranium–zirconium and uranium–plutonium–zirconium has been proposed as a fuel for fast reactors, owing to the possibility of achieving high breeding ratio in a short span of time. About 6–10 wt.% of zirconium has been added to these actinide fuels to increase the melting temperature and thermal-mechanical stability. Aqueous reprocessing of the spent metallic fuel generates the high-level liquid waste (HLLW) that contains about 60 % of the total zirconium from the fuel. In view of this, the extraction behavior of a trivalent representative ion, Nd(III) in the presence of Zr(IV) was studied from nitric acid medium using the candidate ligands proposed for trivalent actinide separation from HLLW, such as N,N,N′N′-tetraoctyldiglycolamide (TODGA), and N,N-di-octyl-2-hydroxyacetamide (DOHyA). The extraction was studied as a function of nitric acid concentration, zirconium and neodymium concentration and Nd(III) to Zr(IV) ratio. The findings of dynamic light scattering (DLS) and ATR-FTIR spectral techniques were used for understanding the complex chemistry of Zr(IV) extraction under different conditions. Poor extraction of nitric acid, smaller aggregate size, no third phase formation during the extraction of Zr(IV) and Nd(III) and other unique solvent properties favor the DOHyA molecule in n-dodecane as a solvent for partitioning of trivalent actinides from HLLW generated from metallic fuel reprocessing.
Acknowledgements
The authors would like to acknowledge the support from Dr. S Ponraju and Mrs. V Snehalatha, Health and Safety Laboratory, IGCAR during ATR-FTIR measurements and Dr. S Vijayalakshmi, Analytical Chemistry and Spectroscopy division, IGCAR for ICP-OES analysis.
References
1. IAEA Nuclear Energy Series No. NF-T-4.2: Status of Developments in the Back End of the Fast Reactor Fuel Cycle. International Atomic Energy Agency, Vienna (2011), p. 15.Suche in Google Scholar
2. Pruett, D. J.: Extraction chemistry of fission products. In: W. W. Schulz, L. L. Burger, J. D. Navratil, K. P. Bender (Eds.), Science and Technology of Tributyl Phosphate. CRC Press, Boca Raton, FL (1990), Vol. III, p. 81.Suche in Google Scholar
3. Lamouroux, C., Moulin, C., Tabet, J. C., Jankowski, C. K.: Characterization of zirconium complexes of interest in spent nuclear fuel reprocessing by electrospray ionization mass spectrometry. Rapid Commun. Mass Spectrom. 14(19), 1869 (2000).10.1002/1097-0231(20001015)14:19<1869::AID-RCM108>3.0.CO;2-PSuche in Google Scholar
4. Wang, L. Y., Lee, M. S.: A review on the aqueous chemistry of Zr (IV) and Hf (IV) and their separation by solvent extraction. J. Ind. Eng. Chem. 39, 1 (2016).10.1016/j.jiec.2016.06.004Suche in Google Scholar
5. Lee, M. S., Lee, H. Y.: Distribution of Zr (IV) ion species in aqueous solution. J. Korean Inst. Resour. Recycl. 20(6), 56 (2011).10.7844/kirr.2011.20.6.056Suche in Google Scholar
6. Singhal, A., Toth, L. M., Lin, J. S., Affholter, K.: Zirconium (IV) tetramer/octamer hydrolysis equilibrium in aqueous hydrochloric acid solution. J Am. Chem. Soc. 118(46), 11529 (1996).10.1021/ja9602399Suche in Google Scholar
7. Zimmer, E., Borchardt, J.: Crud formation in the PUREX and THOREX processes. Nucl. Technol. 75(3), 332 (1986).10.13182/NT86-A33845Suche in Google Scholar
8. Delegard, C. H., Casella, A. J.: Literature Review-Crud Formation at the Liquid/Liquid Interface of TBP-Based Solvent-Extraction Processes. Pacific Northwest National Lab, Richland, WA (United States), No. PNNL-25888 (2016).10.2172/1430463Suche in Google Scholar
9. Carmack, W. J., Porter, D. L., Chang, Y. I., Hayes, S. L., Meyer, M. K., Burkes, D. E., Lee, C. B., Mizuno, T., Delage, F., Somers, J.: Metallic fuels for advanced reactors. J. Nucl. Mater. 392(2), 139 (2009).10.1016/j.jnucmat.2009.03.007Suche in Google Scholar
10. Kaity, S., Banerjee, J., Nair, M. R., Ravi, K., Dash, S., Kutty, T. R. G., Kumar, A., Singh, R. P.: Microstructural and thermophysical properties of U–6 wt.% Zr alloy for fast reactor application, J. Nucl. Mat. 427, 1 (2012).10.1016/j.jnucmat.2012.03.045Suche in Google Scholar
11. Sreenivasulu, B., Suresh, A., Sivaraman, N., Joseph, M.: Studies related to the processing of U-Zr and U-Pu-Zr metallic fuels using tri-iso-amyl phosphate (TiAP) as extractant. Solvent Extr. Ion Exch. 34(5), 422 (2016).10.1080/07366299.2016.1207396Suche in Google Scholar
12. Prathibha, T., Robert Selvan, B., Venkatesan, K. A.: Evaluation of long chain monoamide extractants for the reprocessing of U-Pu-Zr metallic fuel solution. J. Radioanal. Nucl. Chem. 320, 765 (2019).10.1007/s10967-019-06530-9Suche in Google Scholar
13. Gonzalez-Romero, E. M.: Impact of partitioning and transmutation on the high level waste management. Nucl. Eng. Des. 241(9), 3436 (2011).10.1016/j.nucengdes.2011.03.030Suche in Google Scholar
14. Ansari, S. A., Pathak, P. N., Mohapatra, P. K., Manchanda, V. K., Chemistry of diglycolamides – promising extractants for actinide partitioning. Chem. Rev. 112, 1751 (2012).10.1021/cr200002fSuche in Google Scholar PubMed
15. Wilden, A., Modolo, G., Kaufholz, P., Sadowski, F., Lange, S., Sypula, M., Magnusson, D., Müllich, U., Geist, A., Bosbach, D.: Laboratory-scale counter-current centrifugal contactor demonstration of an innovative-SANEX process using a water soluble BTP. Solvent Extr. Ion Exch. 33, 91 (2015).10.1080/07366299.2014.952532Suche in Google Scholar
16. Kannan, S., Vats, B. G., Pius, I. C., Noronha, D. M., Dhami, P. S., Naik, P. W., Kumar, M.: Extraction and structural studies of an unexplored monoamide, N,N′-dioctyl,α-hydroxy acetamide with lanthanide(III) and actinide(III) ions. Dalton Trans. 43, 5252 (2014).10.1039/c3dt53529kSuche in Google Scholar PubMed
17. Prathibha, T., Kumaresan, R., Nayak, P. K., Venkatesan, K. A., Subramanian, G. G. S., Rajeswari, S., Kalaiyarasu, T., Karunakaran, R., Antony, M. P.: Modifier-free separation of trivalent actinides and lanthanides from fast reactor simulated high-level liquid waste using N,N-di-octyl-2-hydroxyacetamide. J. Radioanal. Nucl. Chem. 314, 2365 (2017).10.1007/s10967-017-5528-zSuche in Google Scholar
18. Nave, S., Modolo, G., Madic, C., Testard, F.: Aggregation properties of N,N,N′,N′-tetraoctyl-3-oxapentanediamide (TODGA) in n-dodecane. Solvent Extr. Ion Exch. 22, 527 (2004).10.1081/SEI-120039721Suche in Google Scholar
19. Jensen, M. P., Yaita, T., Chiarizia, R.: Reverse-micelle formation in the partitioning of trivalent f-element cations by biphasic systems containing a tetraalkyldiglycolamide. Langmuir 23, 4765 (2007).10.1021/la0631926Suche in Google Scholar PubMed
20. Prathibha, T., Robert Selvan, B., Venkatesan, K. A., Antony, M. P.: Studies on the radiolytic degradation of N,N-dioctyl-2-hydroxyacetamide using dynamic light scattering and ATR-FTIR spectroscopy. Radiochim. Acta 107(5), 441 (2019).10.1515/ract-2018-3013Suche in Google Scholar
21. Prathibha, T., Venkatesan, K. A., Antony, M. P.: Comparison in the aggregation behaviour of amide extractant systems by dynamic light scattering and ATR-FTIR spectroscopy. Colloids Surf. A-Physiochem. Eng. Asp. 538, 651 (2018).10.1016/j.colsurfa.2017.11.035Suche in Google Scholar
22. Chiarizia, R., Jensen, M. P., Rickert, P. G., Kolarik, Z., Borkowski, M., Thiyagarajan, P.: Extraction of zirconium nitrate by TBP in n-octane: Influence of cation type on third phase formation according to the ‘sticky spheres’ model. Langmuir 20(25), 10798 (2004).10.1021/la0488957Suche in Google Scholar PubMed
23. Déjugnat, C., Dourdain, S., Dubois, V., Berthon, L., Pellet-Rostaing, S., Dufrêche, J. F., Zemb, T.: Reverse aggregate nucleation induced by acids in liquid–liquid extraction processes. Phys. Chem. Chem. Phys. 16, 7339 (2014).10.1039/c4cp00073kSuche in Google Scholar PubMed
24. Koppel, D. E.: Analysis of macromolecular polydispersity in intensity correlation spectroscopy: the method of cumulants. J. Chem. Phys. 57(11), 4814 (1972).10.1063/1.1678153Suche in Google Scholar
25. Sasaki, Y., Zhu, Z. X., Sugo, Y., Suzuki, H., Kimura, T.: Extraction capacity of diglycolamide derivatives for Ca (II), Nd (III) and Zr (IV) from nitric acid to n-dodecane containing a solvent modifier. Anal. Sci. 21(10), 1171 (2005).10.2116/analsci.21.1171Suche in Google Scholar PubMed
26. Prathibha, T., Kumaresan, R., Selvan, B. R., Venkatesan, K. A., Antony, M. P., Rao, P. R. V.: N,N-dialkyl-2-hydroxyacetamides for modifier-free separation of trivalent actinides from nitric acid medium. Radiochim. Acta 104, 173 (2016).10.1515/ract-2015-2477Suche in Google Scholar
27. Zhu, Z. X., Sasaki, Y., Suzuki, H., Suzuki, S., Kimura, T.: Cumulative study on solvent extraction of elements by N,N,N′,N′-tetraoctyl-3-oxapentanediamide (TODGA) from nitric acid into n-dodecane. Anal. Chim. Acta 527(2), 163 (2004).10.1016/j.aca.2004.09.023Suche in Google Scholar
28. Qiao, B., Demars, T., Olvera de la Cruz, M., Ellis, R. J.: How hydrogen bonds affect the growth of reverse micelles around coordinating metal ions. J. Phys. Chem. Lett. 5(8), 1440 (2014).10.1021/jz500495pSuche in Google Scholar PubMed
29. Singh, M. B., Nayak S. G., Kanthe, A. D., Patil, R. B., Gaikar, V. G.: Insight into acidity driven third phase formation of TBP in organic solutions by MD simulation. J Mol. Liq. 232, 1 (2017).10.1016/j.molliq.2017.02.053Suche in Google Scholar
30. Briggs, T. R.: Emulsions with finely divided solids. Ind. Eng. Chem. 13(11), 1008 (1921).10.1021/ie50143a022Suche in Google Scholar
Supplementary Material
The online version of this article offers supplementary material (https://doi.org/10.1515/ract-2019-3220).
©2020 Walter de Gruyter GmbH, Berlin/Boston
Artikel in diesem Heft
- Frontmatter
- Editorial
- Editorial
- Original papers
- Integral measurement of spectrum-averaged cross sections of a few threshold reactions induced by fast neutrons of a TRIGA reactor: comparison with integrated data from excitation functions given in various data libraries
- Quantum chemical studies of selective back-extraction of Am(III) from Eu(III) and Cm(III) with two hydrophilic 1,10-phenanthroline-2,9-bis-triazolyl ligands
- Luminescence of uranium(VI) after liquid-liquid extraction from HCl by Aliquat® 336 in n-dodecane:1-decanol by time-resolved laser-induced luminescence spectroscopy
- Volume oxidation of uranium mononitride and uranium monocarbide in the dry NOX-gaseous atmosphere
- Interference of Zr(IV) during the extraction of trivalent Nd(III) from the aqueous waste generated from metallic fuel reprocessing
- Mild and efficient 64Cu labeling of perhydro-1, 4-diazepine derivatives for potential use with large peptides, proteins and antibodies
- 68Ga CdTe/CdS fluorescent quantum dots for detection of tumors: investigation on the effect of nanoparticle size on stability and in vivo pharmacokinetics
- Natural radioactivity, radon emanating power and mass exhalation rate of environmental soil samples from Karabük province, Turkey
- Enhancing the physico-mechanical properties of irradiated rubber/waste plastic blend via incorporation of different fillers for industrial applications
- Corrigendum
- Corrigendum to: Effect of humic acid, fulvic acid, pH, ionic strength and temperature on 63Ni(II) sorption to MnO2
Artikel in diesem Heft
- Frontmatter
- Editorial
- Editorial
- Original papers
- Integral measurement of spectrum-averaged cross sections of a few threshold reactions induced by fast neutrons of a TRIGA reactor: comparison with integrated data from excitation functions given in various data libraries
- Quantum chemical studies of selective back-extraction of Am(III) from Eu(III) and Cm(III) with two hydrophilic 1,10-phenanthroline-2,9-bis-triazolyl ligands
- Luminescence of uranium(VI) after liquid-liquid extraction from HCl by Aliquat® 336 in n-dodecane:1-decanol by time-resolved laser-induced luminescence spectroscopy
- Volume oxidation of uranium mononitride and uranium monocarbide in the dry NOX-gaseous atmosphere
- Interference of Zr(IV) during the extraction of trivalent Nd(III) from the aqueous waste generated from metallic fuel reprocessing
- Mild and efficient 64Cu labeling of perhydro-1, 4-diazepine derivatives for potential use with large peptides, proteins and antibodies
- 68Ga CdTe/CdS fluorescent quantum dots for detection of tumors: investigation on the effect of nanoparticle size on stability and in vivo pharmacokinetics
- Natural radioactivity, radon emanating power and mass exhalation rate of environmental soil samples from Karabük province, Turkey
- Enhancing the physico-mechanical properties of irradiated rubber/waste plastic blend via incorporation of different fillers for industrial applications
- Corrigendum
- Corrigendum to: Effect of humic acid, fulvic acid, pH, ionic strength and temperature on 63Ni(II) sorption to MnO2
