Improving anti-aging performance of terminal blend rubberized bitumen by using graft activated crumb rubber
-
Juan Xie
,
Xucheng Zhao
Abstract
The appearance of terminal blend rubberized bitumen (TB) has improved a series of defects of traditional rubber bitumen, such as high viscosity, poor storage stability. Therefore, its wide application prospect is self-evident. However, different degrees of thermal-oxidative aging problem still exist in the process from production to use of TB, which seriously affects the service life of pavement. To improve the anti-aging performance of TB, grafting activated crumb rubber (GACR) was obtained by using acrylamide, and then compounded with TB. Firstly, TB was prepared in the self-developed nitrogen protection device. Secondly, GACR modified bitumen (GACR-MB), TB/CR composite modified bitumen (TB/CR) and TB/GACR composite modified bitumen (TB/GACR) were developed in the atmospheric environment. Finally, the performance of four kinds of crumb rubber modified bitumens before and after aging was compared and analyzed by testing high and low temperature rheological properties. The results show that GACR slowed down the formation rate and aggregation degree of asphaltenes and other macromolecular substances, and TB/GACR showed excellent aging resistance.
Funding source: Education Department of Hunan Province
Award Identifier / Grant number: 22A0209
Funding source: National Natural Science Foundation of China
Award Identifier / Grant number: 52178411
Funding source: Changsha University of Science and Technology
Award Identifier / Grant number: CSLGCX23132
Funding source: Hunan Provincial Natural Science Foundation of China
Award Identifier / Grant number: 2023JJ30042
Funding source: Science and Technology Bureau, Changsha
Award Identifier / Grant number: kq2014108
-
Research ethics: Not applicable.
-
Author contributions: All the authors have accepted responsibility for the entire content of this submitted manuscript and approved submission.
-
Competing interests: The authors state no conflict of interest.
-
Research funding: This work was supported by the National Natural Science Foundation of China (52178411), Hunan Provincial Natural Science Foundation of China (2023JJ30042), Scientific Research Project of Hunan Provincial Education Department (22A0209), Changsha Municipal Natural Science Foundation (kq2014108), and Research Innovation Project of Changsha University of Science and Technology (CSLGCX23132).
-
Data availability: The raw data can be obtained on request from the corresponding author.
References
1. Polacco, G., Filippi, S., Merusi, F., Stastna, G. A review of the fundamentals of polymer-modified asphalts: asphalt/polymer interactions and principles of compatibility. Adv. Colloid Interface Sci. 2015, 224, 72–112; https://doi.org/10.1016/j.cis.2015.07.010.Suche in Google Scholar PubMed
2. Milad, A., Ahmeda, A. G. F., Taib, A. M., Rahmad, S., Solla, M., Yusoff, N. I. M. A review of the feasibility of using crumb rubber derived from end-of-life tire as asphalt binder modifier. J. Rubber Res. 2020, 23, 203–216; https://doi.org/10.1007/s42464-020-00050-y.Suche in Google Scholar
3. Picado-Santos, L. G., Capitão, S. D., Neves, J. M. C. Crumb rubber asphalt mixtures: A literature review. Constr. Build. Mater. 2020, 247, 118577; https://doi.org/10.1016/j.conbuildmat.2020.118577.Suche in Google Scholar
4. Zhu, Y., Xu, G., Ma, T., Fan, J., Li, S. Performances of rubber asphalt with middle/high content of waste tire crumb rubber. Constr. Build. Mater. 2022, 335, 127488; https://doi.org/10.1016/j.conbuildmat.2022.127488.Suche in Google Scholar
5. Haihui, D., Chongzheng, Z., Henglong, Z., Shuai, Z., Feipeng, X., Serji, A. Investigation on rheological characteristics of low-emissions crumb rubber modified asphalt. Int. J. Pavement Eng. 2023, 24, 2164891; https://doi.org/10.1080/10298436.2023.2164891.Suche in Google Scholar
6. LinY, Yu, J., Dong, N., Jin, J., Guo, F. Recycling potential of used crumb rubber for second-round asphalt modification. J. Cleaner Prod. 2022, 365, 132797; https://doi.org/10.1016/j.jclepro.2022.132797.Suche in Google Scholar
7. Li, P., Jiang, X., Ding, Z., Zhao, J., Shen, M. Analysis of viscosity and composition properties for crumb rubber modified asphalt. Constr. Build. Mater. 2018, 169, 638–647; https://doi.org/10.1016/j.conbuildmat.2018.02.174.Suche in Google Scholar
8. Xie, J., Zhao, X., Lv, S., Zhang, Y., He, W., Yu, F. Research on performance and mechanism of terminal blend/grafting activated crumb rubber composite modified asphalt. Constr. Build. Mater. 2023, 394, 132225; https://doi.org/10.1016/j.conbuildmat.2023.132225.Suche in Google Scholar
9. Zhang, J., Huang, W., Zhang, Y., Yan, C., Lv, Q., Guan, W. Evaluation of the terminal blend crumb rubber/SBS composite modified asphalt. Constr. Build. Mater. 2021, 278, 122377; https://doi.org/10.1016/j.conbuildmat.2021.122377.Suche in Google Scholar
10. Liu, Z., Wang, Z. Development of terminal blend rubber and SBS modified asphalt: a case study. Constr. Build. Mater. 2022, 334, 127459; https://doi.org/10.1016/j.conbuildmat.2022.127459.Suche in Google Scholar
11. Wang, S., Huang, W., Lin, P., Wu, Z., Kou, C., Wu, B. Chemical, physical, and rheological evaluation of aging behaviors of terminal blend rubberized asphalt binder. J. Mater. Civ. Eng. 2021, 33, 04021302; https://doi.org/10.1061/(asce)mt.1943-5533.0003931.Suche in Google Scholar
12. Huang, W., Lin, P., Tang, N., Hu, J., Xiao, F. Effect of crumb rubber degradation on components distribution and rheological properties of terminal blend rubberized asphalt binder. Constr. Build. Mater. 2017, 151, 897–906; https://doi.org/10.1016/j.conbuildmat.2017.03.229.Suche in Google Scholar
13. Zhang, J., Huang, W., Lv, Q., Guan, W. Low temperature performance of TB crumb rubber composite SBS modified asphalt and mixture. J. Build. Mater. 2021, 24, 131–136; https://doi.org/10.3969/j.issn.1007-9629.2021.01.018.Suche in Google Scholar
14. Li, B., Huang, W., Tang, N., Hu, J., Lin, P., Guan, W., Xiao, F., Shan, Z. Evolution of components distribution and its effect on low temperature properties of terminal blend rubberized asphalt binder. Constr. Build. Mater. 2017, 136, 598–608; https://doi.org/10.1016/j.conbuildmat.2017.01.118.Suche in Google Scholar
15. Tang, N., Lv, Q., Huang, W., Lin, P., Yan, C. Chemical and rheological evaluation of aging characteristics of terminal blend rubberized asphalt binder. Constr. Build. Mater. 2019, 205, 87–96; https://doi.org/10.1016/j.conbuildmat.2019.02.008.Suche in Google Scholar
16. Apostolidis, P., Liu, X., Kasbergen, C., Scarpas, A. T. Synthesis of asphalt binder aging and the state of the art of antiaging technologies. Transp. Res. Rec. 2017, 2633, 147–153; https://doi.org/10.3141/2633-17.Suche in Google Scholar
17. Xie, J., Zhang, Y., Yang, Y. Study on preparation method of terminal blend rubberized asphalt binder. Front. Mater. 2020, 7, 279; https://doi.org/10.3389/fmats.2020.00279.Suche in Google Scholar
18. Ouyang, C., Wang, S., Zhang, Y., Zhang, Y. Improving the aging resistance of asphalt by addition of zinc dialkyldithiophosphate. Fuel 2006, 85, 1060–1066; https://doi.org/10.1016/j.fuel.2005.08.023.Suche in Google Scholar
19. Apeagyei, A. K. Laboratory evaluation of antioxidants for asphalt binders. Constr. Build. Mater. 2011, 25, 47–53; https://doi.org/10.1016/j.conbuildmat.2010.06.058.Suche in Google Scholar
20. Gawel, I., Czechowski, F., Kosno, J. An environmental friendly anti-ageing additive to bitumen. Constr. Build. Mater. 2016, 110, 42–47; https://doi.org/10.1016/j.conbuildmat.2016.02.004.Suche in Google Scholar
21. An, X., Gao, Y., Dong, Z., Guo, Q., Li, L., Li, Y., Sun, X. Effects of commercial antioxidants on aging resistances of asphalt binders. Adv. Mater. Sci. Eng. 2022, 2022, 1–16; https://doi.org/10.1155/2022/7725148.Suche in Google Scholar
22. Zhang, H. L., Luo, H., Duan, H. H., Cao, J. W. Influence of zinc oxide/expanded vermiculite composite on the rheological and anti-aging properties of bitumen. Fuel 2022, 315, 123165; https://doi.org/10.1016/j.fuel.2022.123165.Suche in Google Scholar
23. Zhang, D., Zhang, H., Shi, C. Investigation of aging performance of SBS modified asphalt with various aging methods. Constr. Build. Mater. 2017, 145, 445–451; https://doi.org/10.1016/j.conbuildmat.2017.04.055.Suche in Google Scholar
24. Ma, Y., Wang, S., Zhang, M., Jiang, X., Polaczyk, P., Huang, B. Weather aging effects on modified asphalt with rubber-polyethylene composites. Sci. Total Environ. 2023, 865, 161089; https://doi.org/10.1016/j.scitotenv.2022.161089.Suche in Google Scholar PubMed
25. Kezhen, Y., Guokai, L., Qun, L., Aboelkasim, D., Lingyun, Y., Min, W. Compound modification of asphalt mixture using ethylene-vinyl acetate copolymer and amorphous poly alpha olefin. Constr. Build. Mater. 2022, 341, 127705; https://doi.org/10.1016/j.conbuildmat.2022.127705.Suche in Google Scholar
26. Xie, J., Zhang, Y., Yang, Y., Ma, Y., Li, J., Huang, M. The effect of activation method of rubber on the performance of modified asphalt binder. Materials 2020, 13, 3679; https://doi.org/10.3390/ma13173679.Suche in Google Scholar PubMed PubMed Central
27. Wang, R., Xu, G., Chen, X., Zhou, W., Zhang, H. Evaluation of aging resistance for high-performance crumb tire rubber compound modified asphalt. Constr. Build. Mater. 2019, 218, 497–505; https://doi.org/10.1016/j.conbuildmat.2019.05.124.Suche in Google Scholar
28. Lin, P., Huang, W., Tang, N., Xiao, F., Li, Y. Understanding the low temperature properties of terminal blend hybrid asphalt through chemical and thermal analysis methods. Constr. Build. Mater. 2018, 169, 543–552; https://doi.org/10.1016/j.conbuildmat.2018.02.060.Suche in Google Scholar
29. Wang, Q., Li, S., Wu, X., Wang, S., Ouyang, C. Weather aging resistance of different rubber modified asphalts. Constr. Build. Mater. 2016, 106, 443–448; https://doi.org/10.1016/j.conbuildmat.2015.12.138.Suche in Google Scholar
30. Sarma, A. D., Le, H. H., Das, A., Wießner, S., Stöckelhuber, K. W., Bhowmick, A. K., Heinrich, G. Determination of phase specific localization of carbon black in ternary rubber blends: a macroscopic approach by Fourier transform infrared spectroscopy (FTIR). Polymer 2018, 150, 64–71; https://doi.org/10.1016/j.polymer.2018.07.013.Suche in Google Scholar
31. Li, P., Ding, Z., Cheng, C. Analysis of swelling and degradation characteristics of crumb rubber in hot asphalt. J. South China Univ. Techno. (Nat. Sci. Ed.) 2016, 44, 97–103; https://doi.org/10.3969/j.issn.1000-565X.2016.12.014.Suche in Google Scholar
32. He, L., Ling, T., Ma, Y., Ma, T., Huang, X. Research on asphalt rubber aging performance and characteristics. J. Build. Mater. 2015, 18, 565–571; https://doi.org/10.3969/j.issn.1007-9629.2015.04.006.Suche in Google Scholar
33. Ghavibazoo, A., Abdelrahman, M. Effect of crumb rubber dissolution on low-temperature performance and aging of asphalt–rubber binder. Transp. Res. Rec. 2014, 2445, 47–55; https://doi.org/10.3141/2445-06.Suche in Google Scholar
34. Liang, M., Xin, X., Fan, W., Ren, S., Shi, J., Luo, H. Thermo-stability and aging performance of modified asphalt with crumb rubber activated by microwave and TOR. Mater. Des. 2017, 127, 84–96; https://doi.org/10.1016/j.matdes.2017.04.060.Suche in Google Scholar
35. Tang, N., Dong, R. Anti-aging potential of sulphur in terminal blend rubberized asphalt binder. Constr. Build. Mater. 2020, 250, 118858; https://doi.org/10.1016/j.conbuildmat.2020.118858.Suche in Google Scholar
© 2023 Walter de Gruyter GmbH, Berlin/Boston
Artikel in diesem Heft
- Frontmatter
- Material Properties
- Effect of super critical carbon dioxide and alkali treatment on oxygen barrier properties of thermoplastic starch/poly(vinyl alcohol) films
- Promoting antibacterial activity of polyurethane blend films by regulating surface-enrichment of SiO2 bactericidal agent
- Improving anti-aging performance of terminal blend rubberized bitumen by using graft activated crumb rubber
- An experimental investigation of flame retardancy and thermal stability of treated and untreated kenaf fiber reinforced epoxy composites
- Preparation and properties of ABS/BNNS composites with high thermal conductivity for FDM
- Development of a high-strength carrageenan fiber with a small amount of aluminum ions pre-crosslinked in spinning solution
- Development and characterization of new formulation of biodegradable emulsified film based on polysaccharides blend and microcrystalline wax
- Study on the volatilization behavior of monomer and oligomers in polyamide-6 melt by dynamic film–forming device
- Engineering and Processing
- Numerical simulation on the mixing behavior of double-wave screw under speed sinusoidal pulsating enhancement induced by differential drive
- Numerical and experimental studies on the influence of gas pressure on particle size during gas-assisted extrusion of tubes with embedded antibacterial particles
Artikel in diesem Heft
- Frontmatter
- Material Properties
- Effect of super critical carbon dioxide and alkali treatment on oxygen barrier properties of thermoplastic starch/poly(vinyl alcohol) films
- Promoting antibacterial activity of polyurethane blend films by regulating surface-enrichment of SiO2 bactericidal agent
- Improving anti-aging performance of terminal blend rubberized bitumen by using graft activated crumb rubber
- An experimental investigation of flame retardancy and thermal stability of treated and untreated kenaf fiber reinforced epoxy composites
- Preparation and properties of ABS/BNNS composites with high thermal conductivity for FDM
- Development of a high-strength carrageenan fiber with a small amount of aluminum ions pre-crosslinked in spinning solution
- Development and characterization of new formulation of biodegradable emulsified film based on polysaccharides blend and microcrystalline wax
- Study on the volatilization behavior of monomer and oligomers in polyamide-6 melt by dynamic film–forming device
- Engineering and Processing
- Numerical simulation on the mixing behavior of double-wave screw under speed sinusoidal pulsating enhancement induced by differential drive
- Numerical and experimental studies on the influence of gas pressure on particle size during gas-assisted extrusion of tubes with embedded antibacterial particles
