Catalytic Wet Peroxide Oxidation Process for the Continuous Treatment of Polluted Effluents on a Pilot Plant Scale
-
Fernando Martínez
,
M Isabel Pariente
Abstract
Catalytic Wet Peroxide Oxidation (CWPO) for the continuous treatment of a phenolic aqueous solution has been studied on a pilot scale process. The pilot plant has been designed by integration of a catalytic fixed bed reactor (FBR) with a continuous stirred tank reactor (CSTR). The CSTR is used as reservoir for the continuous delivering of a recirculation stream through the catalytic bed. The main part of phenol mineralization takes place by catalytic oxidation in the FBR. The mesoporous SBA-15 silica-supported iron oxide (Fe2O3/SBA- 15) agglomerated with bentonite has been selected as catalyst, according to preliminary studies for the continuous treatment of phenolic aqueous solutions in a catalytic packed-bed reactor operating in upflow (1). The efficiency of the wet peroxide oxidation treatment under different operation conditions has been evaluated in terms of phenol degradation, total organic carbon (TOC) reduction and hydrogen peroxide conversion. Among the main operation conditions, the feed and recirculation liquid flow rates, the catalyst loading and the temperature in the CSTR were studied. The increase of the residence time as the feed flow rate is reduced has shown a remarkable improvement of the process efficiency, whereas the variation of the recirculation flow through the FBR has slightly affected the overall catalytic performance. A significant enhancement of the process efficiency has been also found as the temperature of the CSTR was increased up to 80 °C. Under the most favourable operating conditions, phenol was almost totally degraded (99%) and TOC was reduced up to ca. 63% at steady-state conditions. In concern to the catalyst stability, a low dissolution of iron within the aqueous solution during the process has been proven.
© 2016 by Walter de Gruyter Berlin/Boston
Articles in the same Issue
- Preface
- An Integral Degradation Model to Describe H2O2-Photooxidation of Linear Alkylbenzenesulfonate (LAS) Surfactants
- Characterization of the Radical Oxidative Level in the Degradation of Phenolic Compounds with H2O2/UV
- Photocatalytic Decolorization of Methylene Blue with Two Photoreactors
- Determination of Quantum Yield in a Heterogeneous Photocatalytic System Using a Fitting-Parameters Model
- Evaluation of Zinc Oxide-Based Photocatalytic Degradation of a Commercial Pesticide
- Photocatalytic Activity of W-Doped TiO2 Nanopowders
- Catalytic Wet Peroxide Oxidation Process for the Continuous Treatment of Polluted Effluents on a Pilot Plant Scale
- Effect of Ultrasound on the Properties of Heterogeneous Catalysts for Sono-Fenton Oxidation Processes
- AOP in Water by Means of a DBD Conducted in a Coaxial Reactor
- Removal of Atrazine from Simulated Groundwater by AOTs
- Modelling Approach to Fenton and Photo-Fenton Treatments
- Chlorobenzene Degradation Assisted by TiO2 under UV Irradiation in Aqueous Solutions
- Optimization of Parameters for Hydrogen Production by Photocatalytic Alcohol Reforming in the Presence of Pt/TiO2 Nanocrystalline Thin Films
- Study on Bipolar Corona Discharge in Emitting Needle Electrode Configuration
- I-V Characteristics of Corona Discharge in Emitting Wire Electrode Configuration
- Micro-pore Ceramic Filter and UV System as Ballast Water Treatment: Preliminary Study on Chlorella Removal and Bacteria Inactivation
- Application of Box–Wilson Experimental Design Method for the Photocatalytic Degradation of Remazol Brilliant Blue R-A with Solar UV/TiO2/Fe(III) Processes
- Treatment of Industrial Cork Processing Water by Ozonation and Ozone Based Advanced Oxidation Processes (O3/UV and O3/H2O2) in a Bubble Column Reactor
- Chemo- and Regio-Selectivity in the TiO2-Mediated Photooxidation of 1,n-diols
- Photosensitized Chlorobenzene Degradation by UV/H2O2 Oxidation
- Influence of Solution Composition and Chemical Structure of Dye on Removal of Organic Dye by DC Diaphragm Discharge in Water solutions
- Photocatalytic Oxidation of Multi-Component Systems – An Investigation Using Toluene/Ethylbenzene, Octane/Decane/Dodecane and Formaldehyde/Acetaldehyde
Articles in the same Issue
- Preface
- An Integral Degradation Model to Describe H2O2-Photooxidation of Linear Alkylbenzenesulfonate (LAS) Surfactants
- Characterization of the Radical Oxidative Level in the Degradation of Phenolic Compounds with H2O2/UV
- Photocatalytic Decolorization of Methylene Blue with Two Photoreactors
- Determination of Quantum Yield in a Heterogeneous Photocatalytic System Using a Fitting-Parameters Model
- Evaluation of Zinc Oxide-Based Photocatalytic Degradation of a Commercial Pesticide
- Photocatalytic Activity of W-Doped TiO2 Nanopowders
- Catalytic Wet Peroxide Oxidation Process for the Continuous Treatment of Polluted Effluents on a Pilot Plant Scale
- Effect of Ultrasound on the Properties of Heterogeneous Catalysts for Sono-Fenton Oxidation Processes
- AOP in Water by Means of a DBD Conducted in a Coaxial Reactor
- Removal of Atrazine from Simulated Groundwater by AOTs
- Modelling Approach to Fenton and Photo-Fenton Treatments
- Chlorobenzene Degradation Assisted by TiO2 under UV Irradiation in Aqueous Solutions
- Optimization of Parameters for Hydrogen Production by Photocatalytic Alcohol Reforming in the Presence of Pt/TiO2 Nanocrystalline Thin Films
- Study on Bipolar Corona Discharge in Emitting Needle Electrode Configuration
- I-V Characteristics of Corona Discharge in Emitting Wire Electrode Configuration
- Micro-pore Ceramic Filter and UV System as Ballast Water Treatment: Preliminary Study on Chlorella Removal and Bacteria Inactivation
- Application of Box–Wilson Experimental Design Method for the Photocatalytic Degradation of Remazol Brilliant Blue R-A with Solar UV/TiO2/Fe(III) Processes
- Treatment of Industrial Cork Processing Water by Ozonation and Ozone Based Advanced Oxidation Processes (O3/UV and O3/H2O2) in a Bubble Column Reactor
- Chemo- and Regio-Selectivity in the TiO2-Mediated Photooxidation of 1,n-diols
- Photosensitized Chlorobenzene Degradation by UV/H2O2 Oxidation
- Influence of Solution Composition and Chemical Structure of Dye on Removal of Organic Dye by DC Diaphragm Discharge in Water solutions
- Photocatalytic Oxidation of Multi-Component Systems – An Investigation Using Toluene/Ethylbenzene, Octane/Decane/Dodecane and Formaldehyde/Acetaldehyde
