Startseite Effect of Introducing Long Chain Branching on Fiber Diameter and Fiber Diameter Distribution in Melt Blowing Process of Polypropylene
Artikel
Lizenziert
Nicht lizenziert Erfordert eine Authentifizierung

Effect of Introducing Long Chain Branching on Fiber Diameter and Fiber Diameter Distribution in Melt Blowing Process of Polypropylene

  • K. Iiba , W. Takarada und T. Kikutani
Veröffentlicht/Copyright: 15. September 2021
Veröffentlichen auch Sie bei De Gruyter Brill

Abstract

In the melt blowing process, the molten polymers extruded from nozzles are elongated by high-velocity and high-temperature air flow. In this study, with the aim of stabilizing the melt blowing process for producing nonwoven webs with fine diameter fibers, the effect of the control of polymer rheology by the introduction of either low melt flow rate (MFR) polypropylene (PP) or long chain branched PP (LCB-PP) to regular high MFR PP was investigated. Introduction of low MFR PP into regular PP increased shear viscosity and fibers of larger diameter were produced in the melt blowing process, while introduction of low MFR LCB-PP suppressed the elongational viscosity reduction with the increase of strain rate, and eventually spinning was stabilized. It was found that the blending of an optimum amount of LCB-PP to regular PP caused the stabilization of the melt blowing process. As a result, the formation of nonwoven webs consisting of fine fibers of rather uniform diameter distribution could be achieved.


Kozo Iiba, Functional Materials Laboratory, Mitsui Chemicals Inc., 580-32, Nagaura, Sodegaura, Chiba 299-0265 Japan


References

Bagley, E. B., "End Corrections in the Capillary Flow of Polyethylene", Polym. Eng. Sci., 28, 624–627 (1957), DOI:10.1063/1.172281410.1063/1.1722814Suche in Google Scholar

Chen, T., Huang, X., "Study on the Flow Field of the Air Jet from Dual Slot Die in the Melt Blowing Process", Polym. Eng. Sci., 41, 971–976 (2001), DOI:10.1002/pen.1079710.1002/pen.10797Suche in Google Scholar

Chhabra, R., Shambaugh, R. L., "Experimental Measurements of Fiber Threadline Vibrations in the Melt-Blowing Process", Ind. Eng. Chem. Res., 35, 4366–4374 (1996), DOI:10.1021/ie960309λ10.1021/ie960309λSuche in Google Scholar

Cogswell, F. N., "Measuring the Extensional Rheology of Polymer Melts", Trans Soc. Rheol., 16, 383–403 (1972), DOI:10.1122/1.54925710.1122/1.549257Suche in Google Scholar

Drabek, J., Zatloukal, M., "Influence of Long Chain Branching on Fiber Diameter Distribution for Polypropylene Nonwovens Produced by Melt Blown Process", J. Rheol., 63, 519–532 (2019), DOI:10.1122/1.504858510.1122/1.5048585Suche in Google Scholar

Drabek, J., Zatloukal, M., "Meltblown Technology for Production of Polymeric Microfibers/Nanofibers: A Review", Phys. Fluids., 31 (2019), DOI:10.1063/1.511633610.1063/1.5116336Suche in Google Scholar

Ellison, C. J., Phatak, A., Giles, D. W., Macosko, C. W. and Bates, F. S., "Melt Blown Nanofibers: Fiber Diameter Distributions and Onset of Fiber Breakup", Polymer, 48, 3306–3316 (2007), DOI:10.1016/j.polymer.2007.04.00510.1016/j.polymer.2007.04.005Suche in Google Scholar

Hao, X., Zeng, Y., "A Review on the Studies of Air Flow Field and Fiber Formation Process during Melt Blowing", Ind. Eng. Chem. Res., 58, 11624–11637 (2019), DOI:10.1021/acs.iecr.9b0169410.1021/acs.iecr.9b01694Suche in Google Scholar

Harpham, A. S., Shambaugh, R. L., "Flow Field of Practical Dual Rectangular Jets", Ind. Eng. Chem. Res., 35, 3776–3781 (1996), DOI:10.1021/ie960309λ10.1021/ie960309λSuche in Google Scholar

Kamin, Z., Sarbatly, R., Krishnaiah, D., Tanioka, A. and Takahashi, M., "Melt Blowing Process Conditions for Nanofibers of Polymers for Oil-Water Separation in Marine Oil Spills Clean-up Applications: A Short Review", J. Mech. Eng. Res. Dev., 42, 205–210 (2019), DOI:10.26480/jmerd.05.2019.205.21010.26480/jmerd.05.2019.205.210Suche in Google Scholar

Lawrence, K. D., Lucas, R. T. and Young, J. A.: An Improved Device for the Formation of Superfine, Thermoplastic Fibers, No. NRL-5265, Naval Research LAB, Washington DC (1959), DOI:10.21236/AD021336710.21236/AD0213367Suche in Google Scholar

Lenk, R. S., "Chapter 7 The Hagen-Poiseuille Equation and the Rabinowitsch Correction. The Pressure Drop in Tapered Channels", in Polymer Rheology, Springer, Dordrecht, p. 75–85 (1978), DOI:10.1007/978-94-010-9666-9_710.1007/978-94-010-9666-9_7Suche in Google Scholar

McCulloch, J. G., "The History of the Development of Melt Blowing Technology", Int. Nonwovens J., os-°, 1 (1999), DOI:10.1177/1558925099os-80012310.1177/1558925099os-800123Suche in Google Scholar

Padmanabhan, M., Macosko, C. W., "Extensional Viscosity from Entrance Pressure Drop Measurements", Rheol. Acta., 36, 144–151 (1997), DOI:10.1007/s00397005003110.1007/s003970050031Suche in Google Scholar

Rao, R. S., Shambaugh, R. L., "Vibration and Stability in the Melt Blowing Process", Ind. Eng. Chem. Res., 32, 3100–3111 (1993), DOI:10.1021/ie00024a02010.1021/ie00024a020Suche in Google Scholar

Ruamsuk, R., Takarada, W. and Kikutani, T., "Fine Filament Formation Behavior of Polymethylpentene and Polypropylene near Spinneret in Melt Blowing Process", Int. Polym. Proc., 31, 217–223 (2016), DOI:10.3139/217.316310.3139/217.3163Suche in Google Scholar

Sedlacek, T., Zatloukal, M., Filip, P., Boldizar, A. and Saha, P., "On the Effect of Pressure on the Shear and Elongational Viscosities of Polymer Melts", Polym. Eng. Sci., 44, 1328–1337 (2004), DOI:10.1002/pen.2012810.1002/pen.20128Suche in Google Scholar

Tan, D. H., Zhou, C., Ellison, C. J., Kumar, S., Macosko, C. W. and Bates, F. S., "Meltblown Fibers: Influence of Viscosity and Elasticity on Diameter Distribution", J. Non-Newtonian Fluid Mech., 165, 892–900 (2010), DOI:10.1016/j.jnnfm.2010.04.01210.1016/j.jnnfm.2010.04.012Suche in Google Scholar

Tate, B. D., Shambaugh, R. L., "Modified Dual Rectangular Jets for Fiber Production", Ind. Eng. Chem. Res., 37, 3772–3779 (1998), DOI:10.1021/ie980219a10.1021/ie980219aSuche in Google Scholar

Tate, B. D., Shambaugh, R. L., "Temperature Fields below Melt-Blowing Dies of Various Geometries", Ind. Eng. Chem. Res., 43, 5405–5410 (2004), DOI:10.1021/ie040066t10.1021/ie040066tSuche in Google Scholar

Received: 2019-12-04
Accepted: 2021-02-08
Published Online: 2021-09-15
Published in Print: 2021-09-27

© 2021 Walter de Gruyter GmbH, Berlin/Boston, Germany

Artikel in diesem Heft

  1. Contents
  2. Regular Contributed Articles
  3. Fiber Length Distribution in Twin-Screw Extrusion of Fiber-Reinforced Polymer Composites: A Comparison between Shear and Extensional Mixing
  4. The Effect of Nanosilicates on the Performance of Polyethylene Terephthalate Films Prepared by Twin-Screw Extrusion
  5. Synergistic Effect between Modified Graphene Oxide and Ammonium Polyphosphate on Combustion Performance, Thermal Stability and Mechanical Properties of Polylactic Acid
  6. Basic Study of Extensional Flow Mixing for the Dispersion of Carbon Nanotubes in Polypropylene by Using Capillary Extrusion
  7. Pulsed IR Heating of Thermoplastic Sheets for Thermoforming Applications
  8. Novel Design and Comparison of Structural and Modal Analyses of Auxetic Geometry versus Honeycomb Geometry
  9. Effect of Introducing Long Chain Branching on Fiber Diameter and Fiber Diameter Distribution in Melt Blowing Process of Polypropylene
  10. Study on the Relationship between the Bonding Surface and Mechanical Properties of PLA/Epoxy Laminated Composites
  11. A Study on Thermal and Electrical Conductivities of Ethylene-Butene Copolymer Composites with Carbon Fibers
  12. Model Approach for Displaying Dynamic Filament Displacement during Impregnation of Continuous Fibres Based on the Theory of Similarity – Theory and Modelling
  13. Using Symbolic Regression Models to Predict the Pressure Loss of Non-Newtonian Polymer-Melt Flows through Melt-Filtration Systems with Woven Screens
  14. Preparation and Photo-Oxidation Aging Behavior of Oriented Polylactic Acid
  15. Numerical Simulation and Process Optimization of a 3D Thin-Walled Polymeric Part Using Injection Compression Molding
  16. PPS News
  17. Seikei-Kakou abstracts
  18. PPS Membership application
Heruntergeladen am 28.10.2025 von https://www.degruyterbrill.com/document/doi/10.1515/ipp-2020-3922/pdf
Button zum nach oben scrollen