Startseite SBA-15 Supported Bimetallic Catalysts for Enhancement Isomers Production During n-Heptane Decomposition
Artikel
Lizenziert
Nicht lizenziert Erfordert eine Authentifizierung

SBA-15 Supported Bimetallic Catalysts for Enhancement Isomers Production During n-Heptane Decomposition

  • Talib M. Albayati EMAIL logo und Aidan M. Doyle
Veröffentlicht/Copyright: 5. April 2014
Veröffentlichen auch Sie bei De Gruyter Brill
Manuskript einreichen Informationen für Autor*innen
International Journal of Chemical Reactor Engineering
Aus der Zeitschrift International Journal of Chemical Reactor Engineering Band 12 Heft 1

Abstract

Santa Barbara Amorphous (SBA)-15 supported 1% (Pt–Ni), 1% (Pt–Co) and 1% (Ni–Co) bimetallic catalysts in a heterogeneous reaction for enhancement hydroisomerization and hydrocracking production during reforming or decomposition of n-heptane. The structural and textural features of the nanoporous silicas, both with and without encapsulated nanoparticles, were characterized using small-angle X-ray diffraction, scanning electron microscopy, EDAX, nitrogen adsorption–desorption porosimetry (Brunauer–Emmett–Teller) surface area analysis, Fourier-transform infrared spectroscopy and transmission electron microscopy. The catalytic performance was evaluated at 250–400°C under atmospheric pressure in a plug-flow reactor in a catalyst testing rig under tightly controlled conditions of temperature, reactant flow rate and pressure. The species leaving the reactor were analysed by Gas Chromatography. The results show that 1% (Pt–Ni)/SBA-15, 1% (Pt–Co)/SBA-15 and 1% (Ni–Co)/SBA-15 had a high activity for conversion of n-heptane (around 85%). The selectivity of isomerization is not high, so further studies have to be carried out in the future.

Keywords: nanoporous material; SBA-15; n-heptane; bimetallic catalyst; hydroisomerization; hydrocracking

Acknowledgements

Dr Talib M. Albayati is grateful to the University of Technology, in Republic of Iraq, for allowing postdoctoral leave and to Manchester Metropolitan University, in Britain, United Kingdom, for financial support.

References

1. ZakumbaevaGD, VanTV, LyashenkoAI, EgizbaevaRI. Catalytic reforming n-octane on Pt–Re/Al2O3 catalysts promoted by different additives. Catalysis Today2001;65:191–4.10.1016/S0920-5861(00)00584-8Suche in Google Scholar

2. WangJA, ChenLF, NorenaLE, NavarreteJ, LlanosME, ContrerasJL, et al. Mesoporous structure, surface acidity and catalytic properties of Pt/Zr–MCM-41 catalysts promoted with 12-tungstophosphoric acid. Microporous Mesoporous Mater2008;112:61–76.10.1016/j.micromeso.2007.09.015Suche in Google Scholar

3. Mc VickerGB, CollinsPJ, ZiemackJJ. Model compound reforming studies: a comparison of alumina-supported platinum and iridium catalysts. J Catalysis1982;74:156–72.10.1016/0021-9517(82)90019-7Suche in Google Scholar

4. EswaramoorthiI, SundaramurthyV, LingappanN.Hydroisomerisation of C6–C7n-alkanes over Pt loaded zirconium containing Al–MCM-41 molecular sieves. Microporous Mesoporous Mater2004;71:109–15.10.1016/j.micromeso.2004.03.016Suche in Google Scholar

5. MaciasO, LargoJ, PesqueraC, BlancoC, GonzálezF. Characterization and catalytic properties of montmorillonite pillared with aluminum/lanthanum. Appl Catalysis A Gen2006;314:23–31.10.1016/j.apcata.2006.07.027Suche in Google Scholar

6. WangJA, ZhouXL, ChenLF, NorenaLE, YuGX, LiCL.Hydroisomerization of n-heptane on the Pt/H3PW12O40/Zr-MCM-41 catalysts. J Mol Catal Chem2009;299:68–76.10.1016/j.molcata.2008.10.016Suche in Google Scholar

7. KingerG, MajdaD, VinekH. N-heptane hydroisomerization over pt-containing mixtures of zeolites with inert materials. Appl Catalysis A: Gen2002;225:301–12.10.1016/S0926-860X(01)00876-6Suche in Google Scholar

8. BustoM, LovatoME, VeraCR, ShimizuK, GrauJM. Silica supported tungsta-zirconia catalysts for hydroisomerization–cracking of long alkanes. Appl Catalysis A: Gen2009;355:123–31.10.1016/j.apcata.2008.12.009Suche in Google Scholar

9. OliveiraAC, EssayemN, TuelA, ClacensJM, TaâriYB. Structural, acidic and catalytic features of transition metal-containing molecular sieves in the transformation of C4 hydrocarbon. Appl Catalysis A: Gen2010;382:10–20.10.1016/j.apcata.2010.04.002Suche in Google Scholar

10. ZhaoD, FengJ, HuoQ, MeloshN, FredricksonGH, ChmelkaBF, et al. Triblock copolymer syntheses of mesoporous silica with periodic 50–300 angstrom pores. Science1998;279:548–52.10.1126/science.279.5350.548Suche in Google Scholar PubMed

11. ZhaoD, HuoQ, FengJ, ChmelkaBF, StuckyGD. Nonionic triblock and star diblock copolymer and oligomeric surfactant syntheses of highly ordered, hydrothermally stable, mesoporous silica structures. J Am Chem Soc1998;120:6024–36.10.1021/ja974025iSuche in Google Scholar

12. BeckJS, VartuliJC, RothWJ, LeonowiczME, KresgeCT, SchmittKD, et al. J Am Chem Soc1992;114:10834.Suche in Google Scholar

13. LiX, LiuX, MaY, LiM, ZhaoJ, XinH, et al. Engineering the formation of secondary building blocks within the hollow interiors. Adv Mater2012;24:1424–8.10.1002/adma.201104167Suche in Google Scholar PubMed

14. KuhnJN, HuangW, TsungC-K, ZhangY, SomorjaiGA. Structure sensitivity of carbon-nitrogen ring opening: impact of platinum particle size from below 1 to 5 nm upon pyrrole hydrogenation product selectivity over monodisperse platinum nanoparticles loaded onto mesoporous silica. J Am Chem Soc2008;130:14026–7.10.1021/ja805050cSuche in Google Scholar PubMed

15. KrukM, JaroniecM, SayariA. Influence of hydrothermal restructuring conditions on structural properties of mesoporous molecular sieves. Chem Mater1999;11:492–500.Suche in Google Scholar

16. ZuoD, LaneJ, CulyD, SchultzM, PullarA, WaxmanM. Sulfonic acid functionalized mesoporous SBA-15 catalysts for biodiesel production. Appl Catalysis B: Environ2013;129:342–50.10.1016/j.apcatb.2012.09.029Suche in Google Scholar

17. ChiuJJ, PineDJ, BishopST, ChmelkaBF. Friedel–craftsalkylation properties of aluminosilica SBA-15 meso/macroporous monoliths and mesoporous powders. J Catalysis2004;221:400–12.10.1016/j.jcat.2003.09.005Suche in Google Scholar

18. TsonchevaT, IvanovaL, MinchevC, FröbaM. Cobalt-modified mesoporous MgO. ZrO2, and CeO2 oxides as catalysts for methanol decomposition. J Colloid and Interface Sci2009;333:277–84.10.1016/j.jcis.2008.12.070Suche in Google Scholar PubMed

19. ZhouL, XuJ, MiaoH, WangF, LiX. Catalytic oxidation of cyclohexane to cyclohexanol and cyclohexanone over Co3O4 nanocrystals with molecular oxygen. Appl Catalysis A Gen2005;292:223–8.10.1016/j.apcata.2005.06.018Suche in Google Scholar

20. DuJ, XuH, ShenJ, HuangJ, ShenW, ZhaoD. Catalytic dehydrogenation and cracking of industrial dipentene over M/SBA–15 (M = Al, Zn) catalysts. Appl Catalysis A: Gen2005;296:186–93.10.1016/j.apcata.2005.08.030Suche in Google Scholar

21. LuanZ, FournierJA. In situ FTIR spectroscopic investigation of active sites and adsorbate interactions in mesoporous aluminosilicate SBA-15 molecular sieves. Microporous Mesoporous Mater2005;79:235–40.10.1016/j.micromeso.2004.11.012Suche in Google Scholar

22. EswaramoorthiI, LingappenN. Ni-Pt/H-Y zeolite catalysts for hydroisomerisation of n-C6 and n-C7. Catalysis Lett2003;87:133–42.Suche in Google Scholar

23. DwyerJ. Zeolite structure, composition and catalysis. Chem Ind1984;7:258–69.Suche in Google Scholar

24. KarthikeyanD, LingappanN, SivasankarB. Hydroisomerisation of n-octane over bifunctional Ni-Pd/HY zeolite catalysts. Ind Eng Chem Res2008;47:6538–46.10.1021/ie7017299Suche in Google Scholar

Published Online: 2014-4-5
Published in Print: 2014-1-1

©2014 by De Gruyter

Artikel in diesem Heft

  1. Frontmatter
  2. Research Articles
  3. Simulation of CO Preferential Oxidation (COPrOx) Monolithic Reactors
  4. Simulation of a New Chemical-Looping Combustion Process without Sulfur Evolution Based on Ca-Based Oxygen Carrier
  5. Syngas Production from Reforming of Methane with CO2 and O2 over LaNi1–xCoxO3 Perovskites
  6. Investigation of the Effect of Outlet Structures on the Jet Flow Characteristics in the Circulating Jet Tank
  7. Transesterification of Sunflower Oil in Microreactors
  8. Influence of the Photoreactor Configuration and of Different Light Sources in the Photocatalytic Treatment of Highly Polluted Wastewater
  9. Stability and Emissions of a Lean Pre-Mixed Combustor with Rich Catalytic/Lean-burn Pilot
  10. Carica Papaya Seed as a Biosorbent for Removal of Cr (VI) and Ni (II) Ions from Aqueous Solution: Thermodynamics and Kinetic Analysis of Experimental Data
  11. Chemical Equilibrium Model and Prediction for Coal Hydrogasification
  12. Use of Experimental Designs to Establish a Kinetic Law for a Gas Phase Photocatalytic Process
  13. Application of Support Vector Machine Modeling on Phase Distribution in the Riser of an LSCFB Reactor
  14. Characteristics of the Bending Moment Acting on an Overhung Shaft in a Stirred Vessel
  15. Conversion of Glycerol into Value-Added Products Over Cu–Ni Catalyst Supported on γ-Al2O3 and Activated Carbon
  16. Analysis of Equilibrium Shifting by Inter-Stage Reactant Feeding in a Series of Isothermal Reactors
  17. Single and Multi-Channel Reactor for Oxidative Coupling of Methane
  18. Effect of Peak Temperature Limitations on the Design of Processes with Cooled Tubular Reactors
  19. Genetic Optimization of Energy Consumption of Pellet Shaft Furnace Combustor Based on Support Vector Machine (SVM)
  20. Effect of CuO on the Thermal Stability of Polyaniline Nanofibers
  21. Kinetics and Mechanism of Formaldehyde-Free Phenol-Glucose Novolac Resin Cured with an Epoxy
  22. Micromixing Characteristics in an Aerated Stirred Tank with Half Elliptical Blade Disk Turbine
  23. Application of Response Surface Methodology and Central Composite Rotatable Design for Modeling and Optimization of Catalyst Compositions in Ethanol Synthesis via CO Hydrogenation
  24. Accurate Measurement of the Photon Flux Received Inside Two Continuous Flow Microphotoreactors by Actinometry
  25. A Non-linear Inverse Problem in Estimating the Reaction Rate Function for an Annular-Bed Reactor
  26. Passive Microextractor with Internal Fluid Recirculation for Two Immiscible Liquids
  27. Oxidative Desulfurization of Dibenzothiophene by Zirconia-Based Catalysts
  28. Studies on Performance Analysis and Computer Aided Design of Inverse Fluidized Bed Bioreactors with Nanosupport Particles
  29. Modeling the Industrial Propylene–Ethylene Copolymerization FBR at Emergency Accidents
  30. Modelling of the Membrane Permeability Effect on the H2 Production Using CFD Method
  31. SBA-15 Supported Bimetallic Catalysts for Enhancement Isomers Production During n-Heptane Decomposition
  32. Effects of Microwave and Ultrasonic-Assisted Aging on the Synthesis of H-ZSM-5 Nanozeolite and Its Catalytic Performance in Methanol Dehydration
  33. Oxydehydrogenation of Ethylbenzene to Styrene: Membrane Reactor Analysis and Design
  34. Methanol Electrooxidation Study on Mesoporous Silica Supported Pt–Co Direct Methanol Fuel Cell Anode
  35. An Experimental Study of the Synthesis of Ultrafine Titania Powder in Plasmachemical Flow-Type Reactor
  36. Tesla Valves in Micromixers
  37. Kinetic Modelling of Photoconversion of Phenol by a Photo-Fenton Reagent and UV
  38. Overall Effectiveness Factor for Slab Geometry in a Three-Phase Reaction System
  39. Effect of Surface Chemistry and Structure of Sludge Particles on Their Co-slurrying Ability with Petroleum Coke
  40. CFD-DEM Modeling of CO2 Capture using Alkali Metal-Based Sorbents in a Bubbling Fluidized Bed
  41. Reaction Kinetics of Catalytic Esterification of Nonanoic Acid with Ethanol over Amberlyst 15
  42. Numerical and Experimental Investigation of the Effect of Geometrical Parameters on the Performance of a Contraction-Expansion Helical Mixer
  43. Comparative Study of Removal of Cadmium (II) and Chromium (III) Ions from Aqueous Solution Using Low-Cost Biosorbent
  44. Ethylation of Ethylbenzene with Ethanol over Mordenite-Based Catalysts: Effects of Acidity, Desilication and Kinetics Analysis
  45. A Two-Phase CFD Modeling Approach to Investigate the Flow Characteristics in Radial Flow Moving-Bed Reactors
  46. Esterification of Free Fatty Acids in Crude Palm Oil Using Sulfated Cobalt–Tin Mixed Oxide Catalysts
  47. Numerical Simulation of Chemical Stripping Process in Resid Fluid Catalytic Cracking Stripper
  48. Experiment on Simultaneous Absorption of NO and SO2 from Sintering Flue Gas by Oxidizing Agents of KMnO4/NaClO
  49. Analysis of the Simultaneous Gas–Liquid CO2 Absorption and Liquid–Gas NH3 Desorption in a Hydrometallurgical Waelz Oxides Purification Process
  50. Investigation on Fluidized Bed Bioreactor Treating Ice Cream Wastewater Using Response Surface Methodology and Artificial Neural Network
  51. Rapid Determination of the Residence Time Distribution (RTD) Function in an Oscillatory Baffled Reactor (OBR) Using a Design of Experiments (DoE) Approach
  52. α-Amylase Aspergillus oryzae Immobilized on Modified Expanded Perlite
  53. Diffusion and Equilibrium Adsorption Coefficients of Aromatic Hydrocarbon Species in Capillary Columns
  54. Design and Optimization of the Preparation of Calcium Carbonate from Calcium Sulfate and Ammonium Bicarbonate
  55. Short Communications
  56. Effect of Different Silicate Supports on the Catalytic Performance of MoVTeO Mixed Oxides in Partial Oxidation of Isobutane
  57. Liquid Flow and Mixing in Bottom Regions of Baffled and Unbaffled Vessels Agitated by Turbine-Type Impeller
  58. Review
  59. Progress in Reactors for High-Temperature Fischer–Tropsch Process: Determination Place of Intensifier Reactor Perspective
  60. Errata
  61. Erratum to Two-Dimensional Modeling of an Externally Irradiated Slurry Photoreactor
  62. Erratum to Photocatalytic Purification of Wastewater Polluted by Odorant Sulfur Compounds Using Titanium Oxide in a Continuous Photoreactor
https://doi.org/10.1515/ijcre-2013-0120
Schlagwörter für diesen Artikel
nanoporous material; SBA-15; n-heptane; bimetallic catalyst; hydroisomerization; hydrocracking

Artikel in diesem Heft

  1. Frontmatter
  2. Research Articles
  3. Simulation of CO Preferential Oxidation (COPrOx) Monolithic Reactors
  4. Simulation of a New Chemical-Looping Combustion Process without Sulfur Evolution Based on Ca-Based Oxygen Carrier
  5. Syngas Production from Reforming of Methane with CO2 and O2 over LaNi1–xCoxO3 Perovskites
  6. Investigation of the Effect of Outlet Structures on the Jet Flow Characteristics in the Circulating Jet Tank
  7. Transesterification of Sunflower Oil in Microreactors
  8. Influence of the Photoreactor Configuration and of Different Light Sources in the Photocatalytic Treatment of Highly Polluted Wastewater
  9. Stability and Emissions of a Lean Pre-Mixed Combustor with Rich Catalytic/Lean-burn Pilot
  10. Carica Papaya Seed as a Biosorbent for Removal of Cr (VI) and Ni (II) Ions from Aqueous Solution: Thermodynamics and Kinetic Analysis of Experimental Data
  11. Chemical Equilibrium Model and Prediction for Coal Hydrogasification
  12. Use of Experimental Designs to Establish a Kinetic Law for a Gas Phase Photocatalytic Process
  13. Application of Support Vector Machine Modeling on Phase Distribution in the Riser of an LSCFB Reactor
  14. Characteristics of the Bending Moment Acting on an Overhung Shaft in a Stirred Vessel
  15. Conversion of Glycerol into Value-Added Products Over Cu–Ni Catalyst Supported on γ-Al2O3 and Activated Carbon
  16. Analysis of Equilibrium Shifting by Inter-Stage Reactant Feeding in a Series of Isothermal Reactors
  17. Single and Multi-Channel Reactor for Oxidative Coupling of Methane
  18. Effect of Peak Temperature Limitations on the Design of Processes with Cooled Tubular Reactors
  19. Genetic Optimization of Energy Consumption of Pellet Shaft Furnace Combustor Based on Support Vector Machine (SVM)
  20. Effect of CuO on the Thermal Stability of Polyaniline Nanofibers
  21. Kinetics and Mechanism of Formaldehyde-Free Phenol-Glucose Novolac Resin Cured with an Epoxy
  22. Micromixing Characteristics in an Aerated Stirred Tank with Half Elliptical Blade Disk Turbine
  23. Application of Response Surface Methodology and Central Composite Rotatable Design for Modeling and Optimization of Catalyst Compositions in Ethanol Synthesis via CO Hydrogenation
  24. Accurate Measurement of the Photon Flux Received Inside Two Continuous Flow Microphotoreactors by Actinometry
  25. A Non-linear Inverse Problem in Estimating the Reaction Rate Function for an Annular-Bed Reactor
  26. Passive Microextractor with Internal Fluid Recirculation for Two Immiscible Liquids
  27. Oxidative Desulfurization of Dibenzothiophene by Zirconia-Based Catalysts
  28. Studies on Performance Analysis and Computer Aided Design of Inverse Fluidized Bed Bioreactors with Nanosupport Particles
  29. Modeling the Industrial Propylene–Ethylene Copolymerization FBR at Emergency Accidents
  30. Modelling of the Membrane Permeability Effect on the H2 Production Using CFD Method
  31. SBA-15 Supported Bimetallic Catalysts for Enhancement Isomers Production During n-Heptane Decomposition
  32. Effects of Microwave and Ultrasonic-Assisted Aging on the Synthesis of H-ZSM-5 Nanozeolite and Its Catalytic Performance in Methanol Dehydration
  33. Oxydehydrogenation of Ethylbenzene to Styrene: Membrane Reactor Analysis and Design
  34. Methanol Electrooxidation Study on Mesoporous Silica Supported Pt–Co Direct Methanol Fuel Cell Anode
  35. An Experimental Study of the Synthesis of Ultrafine Titania Powder in Plasmachemical Flow-Type Reactor
  36. Tesla Valves in Micromixers
  37. Kinetic Modelling of Photoconversion of Phenol by a Photo-Fenton Reagent and UV
  38. Overall Effectiveness Factor for Slab Geometry in a Three-Phase Reaction System
  39. Effect of Surface Chemistry and Structure of Sludge Particles on Their Co-slurrying Ability with Petroleum Coke
  40. CFD-DEM Modeling of CO2 Capture using Alkali Metal-Based Sorbents in a Bubbling Fluidized Bed
  41. Reaction Kinetics of Catalytic Esterification of Nonanoic Acid with Ethanol over Amberlyst 15
  42. Numerical and Experimental Investigation of the Effect of Geometrical Parameters on the Performance of a Contraction-Expansion Helical Mixer
  43. Comparative Study of Removal of Cadmium (II) and Chromium (III) Ions from Aqueous Solution Using Low-Cost Biosorbent
  44. Ethylation of Ethylbenzene with Ethanol over Mordenite-Based Catalysts: Effects of Acidity, Desilication and Kinetics Analysis
  45. A Two-Phase CFD Modeling Approach to Investigate the Flow Characteristics in Radial Flow Moving-Bed Reactors
  46. Esterification of Free Fatty Acids in Crude Palm Oil Using Sulfated Cobalt–Tin Mixed Oxide Catalysts
  47. Numerical Simulation of Chemical Stripping Process in Resid Fluid Catalytic Cracking Stripper
  48. Experiment on Simultaneous Absorption of NO and SO2 from Sintering Flue Gas by Oxidizing Agents of KMnO4/NaClO
  49. Analysis of the Simultaneous Gas–Liquid CO2 Absorption and Liquid–Gas NH3 Desorption in a Hydrometallurgical Waelz Oxides Purification Process
  50. Investigation on Fluidized Bed Bioreactor Treating Ice Cream Wastewater Using Response Surface Methodology and Artificial Neural Network
  51. Rapid Determination of the Residence Time Distribution (RTD) Function in an Oscillatory Baffled Reactor (OBR) Using a Design of Experiments (DoE) Approach
  52. α-Amylase Aspergillus oryzae Immobilized on Modified Expanded Perlite
  53. Diffusion and Equilibrium Adsorption Coefficients of Aromatic Hydrocarbon Species in Capillary Columns
  54. Design and Optimization of the Preparation of Calcium Carbonate from Calcium Sulfate and Ammonium Bicarbonate
  55. Short Communications
  56. Effect of Different Silicate Supports on the Catalytic Performance of MoVTeO Mixed Oxides in Partial Oxidation of Isobutane
  57. Liquid Flow and Mixing in Bottom Regions of Baffled and Unbaffled Vessels Agitated by Turbine-Type Impeller
  58. Review
  59. Progress in Reactors for High-Temperature Fischer–Tropsch Process: Determination Place of Intensifier Reactor Perspective
  60. Errata
  61. Erratum to Two-Dimensional Modeling of an Externally Irradiated Slurry Photoreactor
  62. Erratum to Photocatalytic Purification of Wastewater Polluted by Odorant Sulfur Compounds Using Titanium Oxide in a Continuous Photoreactor
Jetzt anmelden und 20% sparen
Institutioneller Zugang
Wie funktioniert Authentifizierung?
Haben Sie eine Idee, wie wir unsere Website verbessern können?
Bitte schreiben Sie uns.
© 2025 De Gruyter Brill
Heruntergeladen am 10.9.2025 von https://www.degruyterbrill.com/document/doi/10.1515/ijcre-2013-0120/html
Button zum nach oben scrollen