Fischer-Tropsch synthesis (FTS), an exothermic reaction where hydrogen and carbon monoxide synthesis gas are converted to hydrocarbon products, has been under development since the 1930's. The interest in FTS depends on current and perceived future prices of crude oil but is increasingly viewed as an option for exploiting stranded natural gas. Other advantages of FTS hydrocarbons include the absence of sulphur, nitrogen, heavy metal contaminants, low aromatic content and the ability to produce high value middle distillates/fuels. Current interest is directed towards slurry bubble processes comprising gas, liquid, and solid phases. Industrial slurry phase FTS reactors may range in size from 6 10 m in diameter and upwards of 30 m in height and include multiple internal heat transfer tubes. Such systems offer numerous advantages including high heat transfer rates, good mixing, and ease of online catalyst addition and withdrawal. However, one disadvantage is the complex hydrodynamics associated with slurry bubble columns, which make scale-up difficult. A literature review on heat transfer studies and correlations has been completed focusing on previous experimental setups, the synthesis of the key findings/parameters, and the identification of the necessary criteria required for reactor design and scale-up.The parameters having the most pronounced impact on heat transfer in slurry bubble columns and three-phase fluidized beds are the superficial gas velocity and liquid properties such as viscosity and surface tension, which significantly alter the bubble properties and the column hydrodynamics. The effect of particles is poorly understood and is a complex function of particle diameter and concentration. The experimental results and correlations reported here from the majority of studies are dependent upon the equipment and properties of the three phases studied resulting in very limited applicability to other systems or for scale-up. Other concerns include the use of relatively low gas velocities, ambient temperature and pressure, relatively large particles, and relatively small columns employed in most studies, which are not relevant to industrial operating conditions. Furthermore, studies involving multiple internals were relatively few. Most columns were only equipped with a single tube or small heat flux probe thereby measuring only the local heat transfer and not taking into account the effect on column hydrodynamics of multiple internals. Of these studies only a few tubes were equipped with heaters (that did not run the entire tube length) and heat flux probes while the remaining probes were inactive.
Inhalt
- Review
-
Erfordert eine Authentifizierung Nicht lizenziertLiterature Review on Heat Transfer in Two- and Three-Phase Bubble ColumnsLizenziert26. Januar 2009
-
Erfordert eine Authentifizierung Nicht lizenziertTrickle-Bed Laboratory Reactors for Kinetic StudiesLizenziert6. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBiomass Gasification in Supercritical Water -- A ReviewLizenziert28. August 2009
-
Erfordert eine Authentifizierung Nicht lizenziertCharacteristics of Local Flow Dynamics and Macro-Mixing in Airlift Column Reactors for Reliable Design and Scale-UpLizenziert31. Oktober 2009
- Article
-
Erfordert eine Authentifizierung Nicht lizenziertSimulation of the Agro-Biomass(Olive Kernel) Fast Pyrolysis in a Wire Mesh Reactor Considering Intra-Particle Radial and Temporal Distribution of ProductsLizenziert12. Januar 2009
-
Erfordert eine Authentifizierung Nicht lizenziertEsterification of Butyl Cellosolve with Acetic Acid using Ion Exchange Resin in Fixed Bed Chromatographic ReactorsLizenziert12. Januar 2009
-
Erfordert eine Authentifizierung Nicht lizenziertExperiment and CFD Simulation on Gas Holdup Characteristics in an Internal Loop Reactor with External Liquid CirculationLizenziert26. Januar 2009
-
Erfordert eine Authentifizierung Nicht lizenziertExperimental Study on the Performance of a Hybrid Water HeaterLizenziert18. Februar 2009
-
Erfordert eine Authentifizierung Nicht lizenziertModeling of Nitrate Adsorption on Granular Activated Carbon (GAC) using Artificial Neural Network (ANN)Lizenziert25. März 2009
-
Erfordert eine Authentifizierung Nicht lizenziertOptimization of Process Parameters for the Photocatalytic Degradation of 2,4-Dichlorophenol in Aqueous SolutionsLizenziert4. April 2009
-
Erfordert eine Authentifizierung Nicht lizenziertDeactivation of Highly Resistant Microorganisms in Water Using Solar Driven Photocatalytic ProcessesLizenziert4. April 2009
-
Erfordert eine Authentifizierung Nicht lizenziertMathematical Modeling of Gas Oil HDS and Optimization of Operational Conditions in Trickle Bed Reactor by Genetic AlgorithmLizenziert7. April 2009
-
Erfordert eine Authentifizierung Nicht lizenziertDirect Reaction of Silicon with Ethyl Chloride in a Fluidized Bed ReactorLizenziert18. April 2009
-
Erfordert eine Authentifizierung Nicht lizenziertPyrolysis of Acetylene for Vacuum Carburizing of Steel: Modeling with Detailed KineticsLizenziert18. April 2009
-
Erfordert eine Authentifizierung Nicht lizenziertThe Effect of Sound on Diamond Hot Filament Chemical Vapor DepositionLizenziert22. April 2009
-
Erfordert eine Authentifizierung Nicht lizenziertFriedel-Crafts Alkylation of Mesitylene with tert-Butyl Alcohol over Novel Solid Acid Catalyst UDCaT-5Lizenziert6. Mai 2009
-
Erfordert eine Authentifizierung Nicht lizenziertSimulation of Catalytic Dehydrogenation of Cyclohexane in Zeolite Membrane ReactorLizenziert6. Mai 2009
-
Erfordert eine Authentifizierung Nicht lizenziertOssein Waste: A Potential Raw Material for Protease ProductionLizenziert6. Mai 2009
-
Erfordert eine Authentifizierung Nicht lizenziertA Numerical Study of Solid Suspension Layers in a Swirl Fluidised Bed ReactorLizenziert6. Mai 2009
-
Erfordert eine Authentifizierung Nicht lizenziertA Neural Network Approach for Identification and Modeling of Delayed Coking PlantLizenziert6. Mai 2009
-
Erfordert eine Authentifizierung Nicht lizenziertHydrogen Sulfide Removal in Biofilter: Evaluation of a New filter Material by Immobilization of Thiobacillus sp.Lizenziert24. Mai 2009
-
Erfordert eine Authentifizierung Nicht lizenziertKinetics of Benzyl Butyrate Synthesis under Solid-Liquid Phase Transfer CatalysisLizenziert24. Mai 2009
-
Erfordert eine Authentifizierung Nicht lizenziertComputational Fluid Dynamics Modeling of Chemical Looping Combustion Process with Calcium Sulphate Oxygen CarrierLizenziert29. Mai 2009
-
Erfordert eine Authentifizierung Nicht lizenziertSuperadiabatic Lean Catalytic Combustion in a High-Pressure ReactorLizenziert6. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertA Methodology for Controlling Slopping in Copper Converters by Using Lateral and Bottom Gas InjectionLizenziert14. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertCurrent R&D Challenges for Fluidized Bed Processes in the Refining IndustryLizenziert14. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertMathematical Modeling of Fischer-Tropsch Synthesis in an Industrial Slurry Bubble ColumnLizenziert14. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertIntensification of Ester Production in a Continuous ReactorLizenziert14. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertModeling of para-Xylene Synthesis via Nonselective Toluene DisproportionationLizenziert15. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertA Neural Network Approach for Prediction of Main Product Yields in Methanol to Olefins ProcessLizenziert20. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertPreparation of Mesocarbon Microbeads and Subsequent Heating TreatmentLizenziert28. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertOrthogonal Array Design for Optimization of Additives Assisted Cycol-Dehydration of 1,4-Butanediol to Tetrahydrofuran in Near-Critical WaterLizenziert10. August 2009
-
Erfordert eine Authentifizierung Nicht lizenziertDynamical Modelling and Simulation of Wastewater Filtration Process by Submerged Membrane BioreactorsLizenziert10. August 2009
-
Erfordert eine Authentifizierung Nicht lizenziertStudy of Gas Shortcut Flow Rate in Cyclone with Different Inlet Section Angles Using Response Surface MethodologyLizenziert10. August 2009
-
Erfordert eine Authentifizierung Nicht lizenziertCombining Fischer-Tropsch (FT) and Hydrocarbon Reactions under FT Reaction Conditions: Model Compound and Combined-Catalyst StudiesLizenziert12. August 2009
-
Erfordert eine Authentifizierung Nicht lizenziertSelective Oxidation of Ethylene in an Industrial Packed-Bed Reactor: Modelling, Analysis and OptimizationLizenziert12. August 2009
-
Erfordert eine Authentifizierung Nicht lizenziertSorption Kinetics and Equilibrium Analysis for the Removal of Reactive Red 2 and Reactive Blue 81 Dyes from Synthetic Effluents Using Dried Soya Bean MealLizenziert12. August 2009
-
Erfordert eine Authentifizierung Nicht lizenziertEquilibrium and Kinetics of Reactive Extraction of Propionic Acid Using Aliquat 336 and Tri-n-Butyl Phosphate in n-HexanolLizenziert25. August 2009
-
Erfordert eine Authentifizierung Nicht lizenziertCatalyst Support and Pretreatment Effects on Carbon Nanotubes Synthesis by Chemical Vapor Deposition of Methane on Iron over SiO2, Al2O3 or MgOLizenziert3. September 2009
-
Erfordert eine Authentifizierung Nicht lizenziertDirect Oxidation of Dimethylsulphoxide and Reduction of Maleic Acid in Methanesulphonic Acid MediumLizenziert22. September 2009
-
Erfordert eine Authentifizierung Nicht lizenziertNovel Route for Recovery of Glycerol from Aqueous Solutions by Reversible ReactionsLizenziert8. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertModelling and Simulation of Acid Gas Condensation in an Industrial ChimneyLizenziert11. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertProduction of L-Asparaginase from Natural Substrates by Aspergillus terreus MTCC 1782: Effect of Substrate, Supplementary Nitrogen Source and L-AsparagineLizenziert18. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertRemoval of Malachite Green from Aqueous Solutions by PerliteLizenziert23. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertCombined Effect of Surfactant and Ultrasound on Nano Calcium Carbonate Synthesized by Crystallization ProcessLizenziert29. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertWinter Operation of Biofilters for Hydrogen Sulphide RemovalLizenziert31. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertRole of Structural Deficiency of Nanoscaled Perovskites Prepared by Reactive Grinding on the Catalytic Purification of Exhaust PollutantsLizenziert4. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertModeling and Sensitivity Analysis of a Catalyst Pellet with Non-Uniform Activity Distribution in Fischer-Tropsch SynthesisLizenziert4. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertVisible Light Enabled V and Cr Doped Titania-Silica Aerogel PhotocatalystLizenziert5. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertParametric and Sensitivity Analysis of Diesel Particulate Filter RegenerationLizenziert8. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertSimulation of the Effectiveness Factor for a Tri-Lobular Catalyst on the Hydrodesulfurization of DieselLizenziert11. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertOptimal Design, Modeling and Simulation of an Ethanol Steam Reforming ReactorLizenziert11. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertInfluence of Boundary Conditions on CFD Simulation of Gas- particle Hydrodynamics in a Conical Fluidized Bed UnitLizenziert11. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertPerformance Analysis of Anaerobic Downflow Stationary Fixed Film (DSFF) Bioreactors and Software DevelopmentLizenziert11. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertElectrophoretic Deposition of Biocomposite Lignin/Hydroxyapatite Coatings on TitaniumLizenziert16. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertActivity Comparison of MCM-41 and V-MCM-4 Catalysts for Ethanol Selective Oxidation and DRIFTS AnalysisLizenziert17. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertStability and Emission in a LPG-Air Premixed Coaxial Jet Flame Burner under a Wide Range of Operating ConditionsLizenziert17. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertCFD Comparative Investigation of the Performances of Reverse Flow and Uni-Flow Hydrocyclones in the Enrichment of the Phosphate PulpLizenziert28. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertHeat Transfer and Pressure Drop Studies in a Circular Tube Fitted with Straight Half-Twist InsertsLizenziert28. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertTransdermal Drug Delivery by Microneedles: Does Skin Metabolism Matter?Lizenziert28. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertGravity Packing of Same Size Spheres and Investigation of Wall OrderingLizenziert28. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBiodiesel Production from Jatropha curcas Oil Using Potassium Carbonate as an Unsupported CatalystLizenziert28. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertA Comparison of Combustion of Coal Chars in O2/CO2 and O2/N2 Mixtures - Isothermal TGA StudiesLizenziert29. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertSynthesis of Carbon Nanotubes on Macroporous Kaolin Substrate via a New Simple CVD MethodLizenziert29. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertOn the Scale-Up of Uneven DBD Reactor on Removal of Diesel Particulate MatterLizenziert30. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertExperimental Study and Artificial Neural Networks Simulation of Activated Carbon Synthesis in Fluidized Bed ReactorLizenziert1. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertCharacterization of Fluidization and Segregation of Biomass Particles by Combining Image Processing and Pressure Fluctuations AnalysisLizenziert1. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertEvaluation of Structural Properties of Cylindrical Packed Beds Using Numerical Simulations and Tomographic ExperimentsLizenziert1. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertElectrocoagulation of Textile Effluent: RSM and ANN ModelingLizenziert2. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertStability of Liquid-Liquid Stratified Microchannel Flow under the Effects of Boundary SlipLizenziert14. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertAn Environmental Analysis of the Impact of an Accidental Fire in Process IndustriesLizenziert23. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertKinetic Modeling and Sensitivity Analysis of Kinetic Parameters for L-Glutamic Acid Production Using Corynebacterium glutamicumLizenziert23. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertInverse Opal Titania on Optical Fiber for the Photoreduction of CO2 to CH3OHLizenziert24. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertAnalogical Modelling and Numerical Simulation of the Adsorption Process for Poly-Phenothiazine Formaldehyde on Graphite ElectrodesLizenziert1. Januar 2010
- BioEnergy II
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: Group 8 Metal Complexes as Homogeneous Ionic Hydrogenation and Hydrogenolysis Catalysts for the Deoxygenation of Biomass to Petrochemicals - Opportunities, Challenges, Strategies and the Story so FarLizenziert21. August 2009
-
Erfordert eine Authentifizierung Nicht lizenziertTemperature Effect on Hydrogen Production from Reactions between Ethanol and Steam in the Presence of Pd-Ru/Nb2O5-TiO2 CatalystLizenziert23. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: Acid Diphosphates as Catalysts for the Production of Methyl and Ethyl Esters from Vegetable OilsLizenziert23. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: An Assessment of the Kinetics of Butanol Production by Clostridium acetobutylicumLizenziert26. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: Biomass Valorisation by a Hybrid Thermochemical Fractionation ApproachLizenziert4. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: Scale-Up of the Milena Biomass Gasification ProcessLizenziert4. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertEthanol Production from Different Substrates by a Flocculent Saccharomyces cerevisiae StrainLizenziert11. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: Furfural Destruction Kinetics during Sulphuric Acid-Catalyzed Production from BiomassLizenziert28. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: Production of Biodegradable Lubricant from Jatropha curcas and TrimethylolpropaneLizenziert28. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertA Simulation Model of Combined Biogas, Bioethanol and Protein Fodder Co-Production in Organic FarmingLizenziert28. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: Biological Pretreatment with Fungi as a Tool for Improvement of the Enzymatic Saccharification of Eucalyptus globulus Labill to Obtain BioethanolLizenziert30. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: Bio-Ethanol from Municipal Solid Waste (MSW): The UK Potential and Implication for Sustainable Energy and Waste ManagementLizenziert30. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertBioenergy II: Effect of Experimental Conditions on the Slow Batch Pyrolysis of Mixtures of Plastics, Tyres and Forestry Biomass WastesLizenziert20. Dezember 2009
- SFGP 2009
-
Erfordert eine Authentifizierung Nicht lizenziertThermo Chemical Equilibrium Modelling of a Biomass Gasifying Process Using ASPEN PLUSLizenziert12. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertDevelopment of Characterization Techniques of Thermodynamic and Physical Properties Applied to the CO2-DMSO MixtureLizenziert27. Oktober 2009
-
Erfordert eine Authentifizierung Nicht lizenziertCurcumin-Loaded Nanocapsules: Formulation and Influence of the Nanoencapsulation Processes Variables on the Physico-Chemical Characteristics of the ParticlesLizenziert8. November 2009
- GPE 2009
-
Erfordert eine Authentifizierung Nicht lizenziertInfluence of Viscosity Ratio on Droplets Formation in a Chaotic Advection FlowLizenziert4. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertAssessing Reverse Osmosis for Water Recycling in Alcoholic Fermentation ProcessesLizenziert29. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertDynamic Kinetic Resolution of Sec-Alcohols in Ionic Liquids/Supercritical Carbon Dioxide Biphasic SystemsLizenziert1. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertOptimization of an Intermittent Slug Injection System for Sawdust Biomass PyrolysisLizenziert9. Dezember 2009
-
Erfordert eine Authentifizierung Nicht lizenziertSynthesis of Glycerol Carbonate from Glycerol, a By-Product of Biodiesel ProductionLizenziert22. Dezember 2009
- Short Communication or Note
-
Erfordert eine Authentifizierung Nicht lizenziertTemperature Regulation via PI High-Order Sliding-Mode Controller Design: Application to a Class of Chemical ReactorLizenziert6. Juli 2009
-
Erfordert eine Authentifizierung Nicht lizenziertMicellar Enhanced Base Catalyzed Hydrolysis of Ethyl Acetate Using TTABLizenziert4. November 2009
-
Erfordert eine Authentifizierung Nicht lizenziertSynthesis and Characterization of Zn Oxide Hexagonal Nano-Pole Films on Quartz Glass SubstrateLizenziert14. Dezember 2009