Startseite Influence of alkaline modification on different adsorption behavior between ZSM-5 and LSX zeolite for toluene
Artikel
Lizenziert
Nicht lizenziert Erfordert eine Authentifizierung

Influence of alkaline modification on different adsorption behavior between ZSM-5 and LSX zeolite for toluene

  • Yongkang Cui , Ziyi Li , Wei Su EMAIL logo , Yi Xing EMAIL logo , Yingshu Liu , Jiaqing Wang und Quanli Zhang
Veröffentlicht/Copyright: 7. Dezember 2020
Veröffentlichen auch Sie bei De Gruyter Brill
Manuskript einreichen Informationen für Autor*innen
International Journal of Chemical Reactor Engineering
Aus der Zeitschrift International Journal of Chemical Reactor Engineering Band 18 Heft 12

Abstract

Adsorption as an air purification method is widely employed to remove volatile organic compounds with low concentration using zeolites. In this study, ZSM-5 and LSX zeolites modified by alkali metal cations (Li+, Na+ and K+) were used as adsorbents for the abatement of toluene. The adsorption behaviors of toluene onto adsorbents with different pore sizes and cation contents were evaluated systematically based on the experiments of adsorption equilibrium, kinetic diffusion and desorption. Besides, Langmuir and Freundlich model, constant-pattern wave propagation model and Kissinger method were applied to fit with the above experimental data. The adsorption amount followed the sequence of Li-LSX > Na-LSX > K-LSX > Li-ZSM-5 > Na-ZSM-5 > K-ZSM-5 obtained from equilibrium isotherms. LSX zeolites showed twice adsorption capacity on unit volume compared to ZSM-5. The mechanisms of steric hindrances and electrostatic interactions controlling the diffusion rate under high and low concentrations were proposed, respectively. At relatively low loadings of toluene, the diffusion resistances were primarily affected by electrostatic interaction due to preferential adsorption of toluene on cationic sites. While at relatively high loadings, the diffusion resistance was mainly restricted by steric effect because of saturated cationic sites. The strength of adsorbate-adsorbent interactions was assessed by temperature programmed desorption experiments. It showed that both adsorption sites and microporous walls contributed to the desorption energy.

Keywords: adsorption strength; desorption; kinetic diffusion; toluene; zeolite
Corresponding author: Wei SuandYi Xing, School of Energy and Environmental Engineering, University of Science and TechnologyBeijing, 100083, China, E-mail: (Wei Su), (Yi Xing)

Funding source: National Key R&D Program of ChinaNational Science Foundation for Young Scientists of ChinaNational Natural Science Foundation of ChinaBeijing Nova ProgramNational Engineering Laboratory for Mobile Source Emission Control Technology

Award Identifier / Grant number: 2017YFC0210300

Award Identifier / Grant number: 21707007

Award Identifier / Grant number: No. 51774038

Award Identifier / Grant number: NELMS2017A14

Acknowledgements

This work is supported by the National Key R&D Program of China (Grant No. 2017YFC0210300), the National Science Foundation for Young Scientists of China (No. 21707007), the National Natural Science Foundation of China (No. 51774038), Beijing Nova Program (Z171100001117084), Open fund of National Engineering Laboratory for Mobile Source Emission Control Technology (NELMS2017A14).

  1. Author contribution: All the authors have accepted responsibility for the entire content of this submitted manuscript and approved submission.

  2. Research funding: This work is supported by the National Key R&D Program of China (Grant No. 2017YFC0210300), the National Science Foundation for Young Scientists of China (No. 21707007), the National Natural Science Foundation of China (No. 51774038), Beijing Nova Program (Z171100001117084), Open fund of National Engineering Laboratory for Mobile Source Emission Control Technology (NELMS2017A14).

  3. Conflict of interest statement: The authors declare no conflicts of interest regarding this article.

References

Arletti, R., A. Martucci, A. Alberti, L. Pasti, M. Nassi, and R. Bagatin. 2012. “Location of MTBE and Toluene in the Channel System of the Zeolite Mordenite: Adsorption and Host–Guest Interactions.” Journal of Solid State Chemistry 194: 135–42, https://doi.org/10.1016/j.jssc.2012.04.024.Suche in Google Scholar

Bal’zhinimaev, B. S., E. A. Paukshtis, A. V. Toktarev, E. V. Kovalyov, M. A. Yaranova, A. E. Smirnov, and S. Stompel. 2019. “Effect of Water on Toluene Adsorption over High Silica Zeolites.” Microporous and Mesoporous Materials 277: 70–7, https://doi.org/10.1016/j.micromeso.2018.10.023.Suche in Google Scholar

Belaissaoui, B., Y. Le Moullec, and E. Favre. 2016. “Energy Efficiency of a Hybrid Membrane/condensation Process for VOC (Volatile Organic Compounds) Recovery from Air: A Generic Approach.” Energy 95: 291–302, https://doi.org/10.1016/j.energy.2015.12.006.Suche in Google Scholar

Cheng, J., Y. Zhang, T. Wang, H. Xu, P. Norris, and W. P. Pan. 2018. “Emission of Volatile Organic Compounds (VOCs) during Coal Combustion at Different Heating Rates.” Fuel 225: 554–62, https://doi.org/10.1016/j.fuel.2018.03.185.Suche in Google Scholar

Chern, J. M., and Y. W. Chien. 2002. “Adsorption of Nitrophenol onto Activated Carbon: Isotherms and Breakthrough Curves.” Water Research 36: 647–55, https://doi.org/10.1016/s0043-1354(01)00258-5.Suche in Google Scholar

Das, D., V. Gaur, and N. Verma. 2004. “Removal of Volatile Organic Compound by Activated Carbon Fiber.” Carbon 42: 2949–62, https://doi.org/10.1016/j.carbon.2004.07.008.Suche in Google Scholar

Dhital, N. B., H. H. Yang, L. C. Wang, Y. T. Hsu, H. Y. Zhang, L. H. Young, and J. H. Lu. 2019. “VOCs Emission Characteristics in Motorcycle Exhaust with Different Emission Control Devices.” Atmospheric Pollution Research 10: 1498–506, https://doi.org/10.1016/j.apr.2019.04.007.Suche in Google Scholar

Frantz, T. S., W. A. Ruiz, C. A. da Rosa, and V. B. Mortola. 2016. “Synthesis of ZSM-5 with High Sodium Content for CO2 Adsorption.” Microporous and Mesoporous Materials 222: 209–17, https://doi.org/10.1016/j.micromeso.2015.10.022.Suche in Google Scholar

Frising, T., and P. Leflaive. 2008. “Extraframework Cation Distributions in X and Y Faujasite Zeolites: A Review.” Microporous and Mesoporous Materials 114: 27–63, https://doi.org/10.1016/j.micromeso.2007.12.024.Suche in Google Scholar

González, D., J. Colón, A. Sánchez, and D. Gabriel. 2019. “A Systematic Study on the VOCs Characterization and Odour Emissions in a Full-Scale Sewage Sludge Composting Plant.” Journal of Hazardous Materials 373: 733–40, https://doi.org/10.1016/j.jhazmat.2019.03.131.Suche in Google Scholar PubMed

Helfferich, F. G., and G. Klein. 1970. “Multicomponent Chromatography.” Bunseki Kagaku 373: 45–60.Suche in Google Scholar

Jahandar Lashaki, M., J. D. Atkinson, Z. Hashisho, J. H. Phillips, J. E. Anderson, and M. Nichols. 2016. “The Role of Beaded Activated Carbon’s Pore Size Distribution on Heel Formation during Cyclic Adsorption/desorption of Organic Vapors.” Journal of Hazardous Materials 315: 42–51, https://doi.org/10.1016/j.jhazmat.2016.04.071.Suche in Google Scholar PubMed

Ji, Y., H. Yang, and W. Yan. 2019. “Effect of Alkali Metal Cations Modification on the Acid/basic Properties and Catalytic Activity of ZSM-5 in Cracking of Supercritical N-Dodecane.” Fuel 243: 155–61, https://doi.org/10.1016/j.fuel.2019.01.105.Suche in Google Scholar

Kim, K. J., and H. G. Ahn. 2012. “The Effect of Pore Structure of Zeolite on the Adsorption of VOCs and Their Desorption Properties by Microwave Heating.” Microporous and Mesoporous Materials 152: 78–83, https://doi.org/10.1016/j.micromeso.2011.11.051.Suche in Google Scholar

Kissinger, H. E. 1957. “Reaction Kinetics in Differential Thermal Analysis.” Analytical Chemistry 29: 1702–6, https://doi.org/10.1021/ac60131a045.Suche in Google Scholar

Koriabkina, A. O., A. M. de Jong, D. Schuring, J van Grondelle, and R. A. van Stanten. 2002. “Influence of the Acid Sites on the Intracrystalline Diffusion of Hexanes and Their Mixtures.” The Journal of Physical Chemistry B 106: 9559–66, https://doi.org/10.1021/jp014464a.Suche in Google Scholar

Kraus, M., U. Trommler, F. Holzer, F. D. Kopinke, and U. Roland. 2018. “Competing Adsorption of Toluene and Water on Various Zeolites.” Chemical Engineering Journal 351: 356–63, https://doi.org/10.1016/j.cej.2018.06.128.Suche in Google Scholar

Kustov, L., V. Golubeva, A. Korableva, O. Anischenko, N. Yegorushina, and G. Kapustin. 2018. “Alkaline-modified ZSM-5 Zeolite to Control Hydrocarbon Cold-Start Emission.” Microporous and Mesoporous Materials 260: 54–8, https://doi.org/10.1016/j.micromeso.2017.06.050.Suche in Google Scholar

Lhuissier, M., A. Couvert, A. Amrane, A. Kane, and J. L. Audic. 2018. “Characterization and Selection of Waste Oils for the Absorption and Biodegradation of VOC of Different Hydrophobicities.” Chemical Engineering Research and Design 138: 482–9, https://doi.org/10.1016/j.cherd.2018.08.028.Suche in Google Scholar

Li, W. B., J. X. Wang, and H. Gong. 2009. “Catalytic Combustion of VOCs on Non-noble Metal Catalysts.” Catalysis Today 148: 81–7, https://doi.org/10.1016/j.cattod.2009.03.007.Suche in Google Scholar

Li, Z., Y. Liu, Y. Xiong, X. Yi, Z. Wang, Y. Quan, and R. T. Yang. 2015. “Desorption Kinetics of Naphthalene and Acenaphthene over Two Activated Carbons via Thermogravimetric Analysis (TGA).” Energy & Fuels 29: 5303–10, https://doi.org/10.1021/acs.energyfuels.5b01159.Suche in Google Scholar

Li, Z., Y. Liu, X. Yang, X. Yi, C. J. Tsai, M. Meng, and R. T. Yang. 2017. “Performance of Mesoporous Silicas and Carbon in Adsorptive Removal of Phenanthrene as a Typical Gaseous Polycyclic Aromatic Hydrocarbon.” Microporous and Mesoporous Materials 239: 9–18, https://doi.org/10.1016/j.micromeso.2016.09.027.Suche in Google Scholar

Ligotski, R., U. Sager, U. Schneiderwind, C. Asbach, and F. Schmidt. 2019. “Prediction of VOC Adsorption Performance for Estimation of Service Life of Activated Carbon Based Filter Media for Indoor Air Purification.” Building and Environment 149: 146–56, https://doi.org/10.1016/j.buildenv.2018.12.001.Suche in Google Scholar

Lillo-Ródenas, M. A., D. Cazorla-Amorós, and A. Linares-Solano. 2005. “Behaviour of Activated Carbons with Different Pore Size Distributions and Surface Oxygen Groups for Benzene and Toluene Adsorption at Low Concentrations.” Carbon 43: 1758–67, https://doi.org/10.1016/j.carbon.2005.02.023.Suche in Google Scholar

Liu, Y., Y. Gao, N. Yu, C. Zhang, S. Wang, L. Ma, J. Zhao, and R. Lohmann. 2015. “Particulate Matter, Gaseous and Particulate Polycyclic Aromatic Hydrocarbons (PAHs) in an Urban Traffic Tunnel of China: Emission from On-Road Vehicles and Gas-Particle Partitioning.” Chemosphere 134: 52–9, https://doi.org/10.1016/j.chemosphere.2015.03.065.Suche in Google Scholar

Liu, Y., Z. Li, X. Yang, Y. Xing, C. Tsai, Q. Yang, Z. Wang, and R. T. Yang. 2016. “Performance of Mesoporous Silicas (MCM-41 and SBA-15) and Carbon (CMK-3) in the Removal of Gas-phase Naphthalene: Adsorption Capacity, Rate and Regenerability.” RSC Advances 6: 21193–203, https://doi.org/10.1039/c5ra27289k.Suche in Google Scholar

Mahdavi, S., and N. Amini. 2016. “The Role of Bare and Modified Nano Nickel Oxide as Efficient Adsorbents for the Removal of Cd2+, Cu2+, and Ni2+ from Aqueous Solution.” Environmental and Earth Sciences 75: 1468, https://doi.org/10.1007/s12665-016-6270-5.Suche in Google Scholar

Newsome, D., and M. O. Coppens. 2015. “Molecular Dynamics as a Tool to Study Heterogeneity in Zeolites-Effect of Na+ Cations on Diffusion of CO2 and N2 in Na-ZSM-5.” Chemical Engineering Science 121: 300–12, https://doi.org/10.1016/j.ces.2014.09.024.Suche in Google Scholar

Ng, J. C. Y., W. H. Cheung, and G. McKay. 2003. “Equilibrium Studies for the Sorption of Lead from Effluents Using Chitosan.” Chemosphere 52: 1021–30, https://doi.org/10.1016/s0045-6535(03)00223-6.Suche in Google Scholar

Park, Y., G. A. Ayoko, E. Horváth, R. Kurdi, J. Kristof, and R. L. Frost. 2013. “Structural Characterisation and Environmental Application of Organoclays for the Removal of Phenolic Compounds.” Journal of Colloid and Interface Science 393: 319–34, https://doi.org/10.1016/j.jcis.2012.10.067.Suche in Google Scholar PubMed

Qi, Y., L. Shen, J. Zhang, J. Yao, R. Lu, and T. Miyakoshi. 2019. “Species and Release Characteristics of VOCs in Furniture Coating Process.” Environmental Pollution 245: 810–19, https://doi.org/10.1016/j.envpol.2018.11.057.Suche in Google Scholar PubMed

Rasouli, M., N. Yaghobi, S. Chitsazan, and M. H. Sayyar. 2012. “Influence of Monovalent Cations Ion-Exchange on Zeolite ZSM-5 in Separation of Para-Xylene from Xylene Mixture.” Microporous and Mesoporous Materials 150: 47–54, https://doi.org/10.1016/j.micromeso.2011.09.013.Suche in Google Scholar

Rodeghero, E.T. Chenet, A. Martucci, M. Ardit, E. Sarti, and L. Pasti. 2019. “Selective Adsorption of Toluene and N-Hexane Binary Mixture from Aqueous Solution on Zeolite ZSM-5: Evaluation of Competitive Behavior between Aliphatic and Aromatic Compounds.” Catalysis Today 345: 157–64, https://doi.org/10.1016/j.cattod.2019.09.015.Suche in Google Scholar

Sabio, E., F. Zamora, J. Gañan, C. M. González-García, and J. F. González. 2006. “Adsorption of P-Nitrophenol on Activated Carbon Fixed-Bed.” Water Research 40: 3053–60, https://doi.org/10.1016/j.watres.2006.06.018.Suche in Google Scholar PubMed

Serra, R. M., E. E. Miró, M. K. Sapag, and A. V. Boix. 2011. “Adsorption and Diffusion of Toluene on Na and Cs Mordenites for Hydrocarbon Traps.” Microporous and Mesoporous Materials 138: 102–9, https://doi.org/10.1016/j.micromeso.2010.09.024.Suche in Google Scholar

Tsai, J. H., H. M. Chiang, G. Y. Huang, and H. L. Chiang. 2008. “Adsorption Characteristics of Acetone, Chloroform and Acetonitrile on Sludge-Derived Adsorbent, Commercial Granular Activated Carbon and Activated Carbon Fibers.” Journal of Hazardous Materials 154: 1183–91, https://doi.org/10.1016/j.jhazmat.2007.11.065.Suche in Google Scholar PubMed

Wang, G., B. Dou, Z. Zhang, J. Wang, H. Liu, and Z. Hao. 2015. “Adsorption of Benzene, Cyclohexane and Hexane on Ordered Mesoporous Carbon.” Journal of Environmental Sciences 30: 65–73, https://doi.org/10.1016/j.jes.2014.10.015.Suche in Google Scholar PubMed

Wu, H., H. Yan, Y. Quan, H. Zhao, N. Jiang, and C. Yin. 2018. “Recent Progress and Perspectives in Biotrickling Filters for VOCs and Odorous Gases Treatment.” Journal of Environmental Management 222: 409–19, https://doi.org/10.1016/j.jenvman.2018.06.001.Suche in Google Scholar PubMed

Yamamoto, T., S. Kataoka, and T. Ohmori. 2010. “Characterization of Carbon Cryogel Microspheres as Adsorbents for VOC.” Journal of Hazardous Materials 177: 331–5, https://doi.org/10.1016/j.jhazmat.2009.12.036.Suche in Google Scholar PubMed

Yang, X., H. Yi, X. Tang, S. Zhao, Z. Yang, Y. Ma, T. Feng, and X. Cui. 2018. “Behaviors and Kinetics of Toluene Adsorption-Desorption on Activated Carbons with Varying Pore Structure.” Journal of Environmental Sciences 67: 104–14, https://doi.org/10.1016/j.jes.2017.06.032.Suche in Google Scholar PubMed

Yang, C., G. Miao, Y. Pi, Q. Xia, J. Wu, Z. Li, and J. Xiao. 2019. “Abatement of Various Types of VOCs by Adsorption/catalytic Oxidation: A Review.” Chemical Engineering Journal 370: 1128–53, https://doi.org/10.1016/j.cej.2019.03.232.Suche in Google Scholar

Zhang, X., B. Gao, A. E. Creamer, C. Cao, and Y. Li. 2017. “Adsorption of VOCs onto Engineered Carbon Materials: A Review.” Journal of Hazardous Materials 338: 102–23, https://doi.org/10.1016/j.jhazmat.2017.05.013.Suche in Google Scholar PubMed

Zhang, Y., F. Jin, Z. Shen, R. Lynch, and A. Al-Tabbaa. 2018. “Kinetic and Equilibrium Modelling of MTBE (Methyl Tert-Butyl Ether) Adsorption on ZSM-5 Zeolite: Batch and Column Studies.” Journal of Hazardous Materials 347: 461–9, https://doi.org/10.1016/j.jhazmat.2018.01.007.Suche in Google Scholar PubMed

Zhang, G., Y. Liu, S. Zheng, and Z. Hashisho. 2019. “Adsorption of Volatile Organic Compounds onto Natural Porous Minerals.” Journal of Hazardous Materials 364: 317–24, https://doi.org/10.1016/j.jhazmat.2018.10.031.Suche in Google Scholar PubMed

Zhou, H. C., Z. P. Zhong, B. S. Jin, Y. J. Huang, and R. Xiao. 2005. “Experimental Study on the Removal of PAHs Using In-Duct Activated Carbon Injection.” Chemosphere 59: 861–9, https://doi.org/10.1016/j.chemosphere.2004.11.022.Suche in Google Scholar PubMed

Supplementary Material

The online version of this article offers supplementary material (https://doi.org/10.1515/ijcre-2020-0105).

Received: 2020-07-12
Accepted: 2020-10-24
Published Online: 2020-12-07

© 2020 Walter de Gruyter GmbH, Berlin/Boston

Artikel in diesem Heft

  1. Articles
  2. Application of statistical analysis, Deng’s relevancy and BP neural network for predicting molten iron sulfur in COREX process
  3. Batch and packed bed techniques for adsorptive aqueous phase removal of selected phenoxyacetic acid herbicide using sugar industry waste ash
  4. Fluidization characteristics of wide-size-distribution particles in a gas-solid fluidized bed reactor
  5. Separation of copper and indium from zinc hydrometallurgy solution
  6. Reactor engineering calculations with a detailed reaction mechanism for the oxidative coupling of methane
  7. Influence of alkaline modification on different adsorption behavior between ZSM-5 and LSX zeolite for toluene
  8. Esterification of glycerol with acetic acid using a sulfonated polyphenylene sulfide non-woven fabric as a catalyst
  9. Effect of H/D ratio and impeller type on power consumption of agitator in continuous stirred tank reactor for nitrocellulose production from cotton linter and nitric acid
  10. Retraction
  11. Retraction note
https://doi.org/10.1515/ijcre-2020-0105
Schlagwörter für diesen Artikel
adsorption strength; desorption; kinetic diffusion; toluene; zeolite

Artikel in diesem Heft

  1. Articles
  2. Application of statistical analysis, Deng’s relevancy and BP neural network for predicting molten iron sulfur in COREX process
  3. Batch and packed bed techniques for adsorptive aqueous phase removal of selected phenoxyacetic acid herbicide using sugar industry waste ash
  4. Fluidization characteristics of wide-size-distribution particles in a gas-solid fluidized bed reactor
  5. Separation of copper and indium from zinc hydrometallurgy solution
  6. Reactor engineering calculations with a detailed reaction mechanism for the oxidative coupling of methane
  7. Influence of alkaline modification on different adsorption behavior between ZSM-5 and LSX zeolite for toluene
  8. Esterification of glycerol with acetic acid using a sulfonated polyphenylene sulfide non-woven fabric as a catalyst
  9. Effect of H/D ratio and impeller type on power consumption of agitator in continuous stirred tank reactor for nitrocellulose production from cotton linter and nitric acid
  10. Retraction
  11. Retraction note
Jetzt anmelden und 20% sparen
Institutioneller Zugang
Wie funktioniert Authentifizierung?
Haben Sie eine Idee, wie wir unsere Website verbessern können?
Bitte schreiben Sie uns.
© 2025 De Gruyter Brill
Heruntergeladen am 16.11.2025 von https://www.degruyterbrill.com/document/doi/10.1515/ijcre-2020-0105/html?lang=de
Button zum nach oben scrollen